Club Car IntelliTach XRT 1550, Руководство по техническому обслуживанию и ремонту

Страница: 491 / 564

2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual Page 15-1
15
SECTION 15 – RADIATOR AND COOLANT
SYSTEM (DIESEL)
ý
DANGER
• See General Warning, Section 1, Page 1-1.
ý
WARNING
• See General Warning, Section 1, Page 1-1.
GENERAL INFORMATION
See General Warning, Section 1, Page 1-1.
The diesel vehicle is equipped with a cooling system that includes a radiator, an electric radiator fan, a reser-
voir, and a circulating system. This cooling system circulates coolant through the engine and across a ther-
mostat.
ENGINE COOLANT LEVEL CHECK
See Engine Coolant – Diesel Vehicles, Section 10a, Page 10a-16.
ENGINE COOLANT CHANGE
1. Turn the key switch OFF and remove the key. Place the Forward/Reverse handle in NEUTRAL and
chock the rear wheels.
2. Disconnect the battery cables as instructed. See WARNING “To avoid unintentionally starting...” in
See General Warning, Section 1, Page 1-1.
3. Raise the hood and remove the reservoir cap. See following WARNING.
ý
WARNING
• Coolant reservoir and radiator are pressurized. Remove caps slowly to relieve pressure.
• Hot! Coolant system is pressurized. Do not remove radiator cap while engine is hot.
4. Place a large drain pan under the radiator and engine drain plugs.
5. Turn the drain valve at the radiator counterclockwise, for one and one-half turns only, to drain coolant
from radiator. See following NOTE.
NOTE: The radiator drain valve does not have a drain STOP position. It can be removed from the radiator
if turned more than one and one-half rotations.
6. Turn the drain valve on the engine counterclockwise to drain coolant (Figure 15-1, Page 15-2) .
7. Remove the engine block coolant plug from the top rear of engine (Figure 15-2, Page 15-2) . See fol-
lowing NOTE.