Club Car IntelliTach XRT 1550, Руководство по техническому обслуживанию и ремонту

Страница: 439 / 564

DIESEL ENGINE, MUFFLER, FUEL SYSTEM, AND CLUTCHES Fuel System
2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual Page 13c-9
13C
FUEL LINES
See General Warning, Section 1, Page 1-1.
The fuel lines must be properly routed and all hose clamps must be tight (Figure 13c-8, Page 13c-8) . The
fuel lines should be kept clean. See following NOTE and WARNING.
NOTE: Use only 5/16-inch and 3/16-inch hoses with SAE J30R7 rating to replace the fuel lines.
ý
WARNING
• Make sure fuel lines are the correct length and are properly routed. Failure to heed this
warning could result in damage to the fuel lines and fire.
FUEL FILTER REPLACEMENT
See General Warning, Section 1, Page 1-1.
The fuel system contains two fuel filters: A primary fuel filter (7) and a secondary fuel filter (8) with an inte-
grated water separator
(Figure 13c-8, Page 13c-8) . Fuel filters, fuel lines, and the fuel tank vent (6) should be
inspected periodically for leaks and replaced when necessary. Fuel filter changes should not exceed the rec-
ommended interval.
See Periodic Service Schedule on page 10a-1. See following NOTE.
NOTE: Use only OEM fuel filters designed for your engine.
DRAINING WATER FROM THE SECONDARY FUEL FILTER
The secondary fuel filter also functions as a water separator. It has a drain valve on the bottom of the filter to
drain water from the fuel system. Water should be drained from the secondary fuel filter/water separator daily.
The fuel filter is mounted on a plate under the passenger-side seat
(Figure 13c-9, Page 13c-9) .
Figure 13c-9 Water Separator Drain Valve
Water Separator
Drain Valve
Secondary
Fuel
Filter