![background image](http://html1.mh-extra.com/html/ducati/monster-s4-fogarty-2002/monster-s4-fogarty-2002_workshop-manual_2537693044.webp)
44
Manutenzione / Maintenance
❍
Top up to the max level using
the brake fluid specified.
▲
Reassemble all components
previously removed.
Rear brake
❍
Check through the slot between
the two caliper halves that there is
at least
1 mm
of friction material on
the pads.
Caution
If one of the pads is worn,
then change both pads.
To change the pads, proceed as
follows:
❍
Remove the spring clip (2) (on caliper
inner side) from the pad retaining pin.
❍
Force the caliper pistons back into
their seats by forcing the brake pads
apart.
❍
Pull the pad retaining pin (1) outwards
and remove.
❍
Remove the pad retaining spring (3)
from between the two caliper halves.
❍
Remove the worn pads.
Note
Change pads which are shiny
or vitrified.
▲
Insert the new pads and the
spring (3).
▲
Insert the centering pin (1) and fix
it in place with the spring clip (2);
the safety tab (A) must be pointing
towards the wheel.
▲
Operate the brake pedal
repeatedly so that the pads bed in
under the action of the brake fluid.
●
Check that the brake fluid level in
the master cylinder reservoir is
between the
MIN
and
MAX
marks. If this is not the case,
unscrew the reservoir cap (4) and
top up with brake fluid.
Note
Should pads be hard to
replace, undo fastening screws and
remove brake calipers.
Warning
Safety components. Follow
the procedure set forth under
section “
Frame
” and, at
reassembly, pay special attention to
brake calipers retaining screws
tightening torque.
A
2
1
4
2
3
1
❍
Rabboccare con liquido prescritto
fino al livello massimo.
▲
Rimontare i componenti rimossi.
Freno posteriore
❍
Controllare attraverso la fessura
ricavata tra le due semipinze che
risulti visibile almeno
1 mm
di
materiale di attrito sulle pastiglie.
Importante
Se anche una sola delle
pastiglie risulta consumata sarà
necessario sostituirle entrambe.
Procedere alla sostituzione delle
pastiglie in questo modo:
❍
Rimuovere la copiglia di sicurezza
(2) (sul lato interno della pinza) dal
perno tenuta pastiglie.
❍
Spingere i pistoncini della pinza
completamente dentro ai propri
aloggiamenti, divaricando le
pastiglie usate.
❍
Sfilare il perno (1) di tenuta
pastiglie verso l’esterno.
❍
Rimuovere la molla (3) di tenuta
pastiglie posta tra le semipinze.
❍
Sfilare le pastiglie usurate.
Note
Sostituire le pastiglie che
presentano un aspetto lucido o
“vetroso”.
▲
Inserire le pastiglie nuove e
relativa molla (3).
▲
Infilare il perno di centraggio (1) e
bloccarlo con la copiglia di sicurezza
(2) orientando il bordino (A) verso la
ruota.
▲
Azionare ripetutamente il pedale
del freno per permettere
l’assestamento delle pastiglie sotto
l’azione di spinta del liquido freni.
●
Verificare che il livello del
serbatoio risulti compreso tra le
tacche di
MIN
e di
MAX
. In caso
contrario provvedere al rabbocco
dopo aver svitato il tappo (4) del
serbatoio.
Note
Se l'operazione di
sostituzione pastiglie dovesse
risultare difficoltosa, rimuovere le
pinze, svitando le viti di fissaggio.
Attenzione
Essendo le pinze freno un
organo di sicurezza della moto,
attenersi a quanto riportato alla
sezione
"Mototelaio"
ed in
particolare fare attenzione in fase di
rimontaggio alla coppia di serraggio
delle viti di fissaggio delle pinze.
Summary of Contents for monster S4 fogarty 2002
