TROUBLESHOOTING AND ELECTRICAL SYSTEM: 850 GAS
Test Procedures
2007-2008 XRT 800, 810 and 850 Maintenance and Service Manual
Page 12-19
12
the reading is between 14.7 and 15.3 volts, the regulator is good. If the reading is lower than 14.7 volts
but rising steadily, check battery condition.
See Hydrometer Test on page 12-9.
If the reading is lower
than 14.7 volts and not rising, and the starter/generator is good; or if the reading is over 15.3 volts and
continues to rise, replace voltage regulator.
See Voltage Regulator Removal on page 14-11.
TEST PROCEDURE 12 – DISCONNECTED KILL WIRE
See General Warning on page 1-1.
NOTE:
Keep the battery connected while performing this test procedure.
1. Place the Forward/Reverse handle in the NEUTRAL position and the neutral lockout switch in the MAIN-
TENANCE position. Chock the wheels.
2. Disconnect the engine kill white/black wire at the bullet connector located next to the RPM limiter
(Figure 12-17, Page 12-20)
.
3. Start the engine in a well ventilated area.
•
Turn the key switch to the ON position. Press the accelerator pedal to start the engine.
4. If the engine begins to run, test the engine kill circuit for a shorted wire or other failed components in the
engine kill circuit.
See Test Procedure 17 – Key Switch (Engine Kill Circuit) on page 12-27.
See fol-
lowing WARNING.
ý
WARNING
• When the white/black engine kill wire is disconnected, the engine will not stop running after
the accelerator pedal is released. It will be necessary to pull and hold the choke handle until
the engine stops running.
5. If the engine does not run, proceed to Test Procedure 13 – Ignition Spark on page 12-20.
Figure 12-15 Voltage Regulator Test
1. Voltage Regulator 2. Solenoid 3. Battery 4. 20 VDC Setting
RE
D
2m
20
m
200
m
2k
200
200
200
200
20
2
200
m
500
20k
200k
2000
k
1000
OFF
WAVETEK
5XL
V
V
V
A
!
!
COM
200nA
MAX
1000 ---
750V
FUSED
4
2
1
3
Summary of Contents for 2007 XRT 800
