![background image](http://html1.mh-extra.com/html/club-car/2007-xrt-800/2007-xrt-800_maintenance-service-manual_2626829263.webp)
ELECTRICAL COMPONENTS: 850 GASOLINE VEHICLE
Battery
2007-2008 XRT 800, 810 and 850 Maintenance and Service Manual
Page 14-31
14
ý
CAUT ION
• If battery wire terminals are damaged or corroded, replace or clean them as necessary. Failure
to do so may cause them to overheat during operation and could result in a fire, property
damage, or personal injury.
2. The battery should be kept clean and dry to prevent self-discharge. Any dirt, grime or acid spillage should
be removed. Wash the battery with a bristle brush using water and bicarbonate of soda (1 cup (237 mL)
baking soda per 1 gallon (3.8 L) of water). Rinse with water. Do not allow solution to enter battery through
the vent cap holes.
See Self-Discharge on page 14-31.
3. Maintain proper water level.
See Water Level on page 14-31.
4. Check battery periodically to see that it is in a full state of charge.
See Charging the Battery on
page 14-33.
5. Keep battery hold-down clamp tight.
See Vibration Damage on page 14-32.
Self-Discharge
Dirt and battery acid can provide a path for a small current draw that slowly discharges the battery. To prevent
self-discharge, the battery should always be kept clean.
Hot weather also has an effect on a battery’s self-discharge rate. The higher the temperature, the quicker a
battery will discharge. In hotter climates, therefore, the battery should be checked more often. When storing
the battery, keep in a cool place.
See Battery Storage on page 14-33.
Water Level
The water level should be checked semi-annually to be sure water is at its proper level
(Figure 14-32,
Page 14-31)
. Never allow the water level to fall below the tops of the plates because this will cause the
exposed part of the plate to become permanently inactive. Check the water level more frequently in hot
weather or when the battery becomes old.
Figure 14-32 Battery Electrolyte Level
1. Level Indicator 2. Cap 3. Plates
Electrolyte level at least 1/2 inch (13 MM) above plates or to
level indicator.
1
3
2
Summary of Contents for 2007 XRT 800
