TROUBLESHOOTING AND ELECTRICAL SYSTEM: 800 AND 810 GAS
Test Procedures
2007-2008 XRT 800, 810 and 850 Maintenance and Service Manual
Page 11-23
11
TEST PROCEDURE 15 – RPM LIMITER
See General Warning on page 1-1.
1. Turn the key switch OFF and remove the key. Place the Forward/Reverse handle in the NEUTRAL posi-
tion. Chock the wheels.
2. Disconnect the battery cables as instructed.
See WARNING “To avoid unintentionally starting...” in
General Warning on page 1-2.
3. Disconnect both of the bullet terminals
(Figure 11-23, Page 11-23)
.
4. Using a multimeter set to 200 ohms, place the red (+) probe on the brown ground wire and place the
black (–) probe on one of the black wire female bullet connectors. The reading should be no continuity.
If the reading is not correct, replace the RPM limiter.
5. This test will find most bad RPM limiters. Some of them may bench test okay but fail under a load due
to heat while operating. Another method of testing is to replace the RPM limiter and then run the engine.
If the engine runs properly, keep the new RPM limiter in the circuit.
TEST PROCEDURE 16 – IGNITION COIL
See General Warning on page 1-1.
The following test procedures will properly detect a coil that has failed in most cases; however, in rare cases,
some ignition coils can fail to operate at normal (warmer) operating temperatures. If the ignition coil has tested
okay in the vehicle and on the bench, but fails to operate reliably, replace the coil with a known good coil and
operate the engine for several minutes to ensure that the coil functions at normal operating temperature. If the
new coil functions properly, keep the new coil in the circuit.
Figure 11-23 RPM Limiter
FEMALE BULLET
TERMINAL
BLACK WIRE
BROWN WIRE
RPM LIMITER
FEMALE BULLET
TERMINAL
BLACK WIRE
TO IGNITION COIL
WHITE/BLACK
KILL CIRCUIT WIRE
Summary of Contents for 2007 XRT 800
