![background image](http://html1.mh-extra.com/html/club-car/2007-xrt-800/2007-xrt-800_maintenance-service-manual_2626829301.webp)
FUEL SYSTEM: GASOLINE VEHICLE
Fuel Lines
2007-2008 XRT 800, 810 and 850 Maintenance and Service Manual
Page 16-25
16
FUEL LINES
See General Warning on page 1-1.
The fuel lines must be properly routed, and all hose clamps must be tight. The fuel lines should be kept clean.
See following WARNING.
ý
WARNING
• Make sure fuel lines are the right length and are properly routed. Failure to heed this warning
could result in damage to fuel lines and fire.
Fuel line no. 1 runs directly from the fuel tank to the primary fuel filter (17). The primary fuel filter (17) has an
arrow indicating fuel flow direction
(Figure 16-13, Page 16-18)
.
Fuel line no. 2 runs directly from the primary fuel filter to the fuel inlet of the fuel pump.
Fuel line no. 3 runs directly from the fuel outlet of the fuel pump to the secondary fuel filter
(Figure 16-13,
Page 16-18)
. The secondary fuel filter has an arrow indicating fuel flow direction and is identical to the primary
fuel filter.
Fuel line no. 4 runs from the outlet of the secondary fuel filter to the carburetor
(Figure 16-13, Page 16-18)
.
Small spring steel band clamps are used on all hose connections except at the carburetor. A screw band
clamp (16) should be used at the carburetor
(Figure 16-13, Page 16-18)
.
FUEL SHUT-OFF VALVE
See General Warning on page 1-1.
The fuel shut-off valve is located on top of the fuel tank
(Figure 16-18, Page 16-25 or Figure 16-19,
Page 16-25)
. The fuel shut-off valve should always be turned to the closed (OFF) position during vehicle stor-
age, towing or trailering. Unless the engine will be run as part of a procedure, the fuel shut-off valve should
also be closed (OFF) before performing maintenance or service procedures.
Figure 16-18 Fuel Shut-off Valve –
49-State Fuel Tank Shown
Figure 16-19 Fuel Shut-off Valve –
California Fuel Tank Shown
1. Fuel Shut-off Valve 2. Closed (OFF) 3. Open (ON)
NOTE: When selecting valve position, ensure that it is fully
opened or fully closed.
1. Fuel Shut-off Valve 2. Closed (OFF) 3. Open (ON)
NOTE: When selecting valve position, ensure that it
is fully opened or fully closed.
1
2
3
2
1
3
Summary of Contents for 2007 XRT 800
