Club Car 2007 XRT 800, Maintenance Service Manual

Page: 125 / 516

2007-2008 XRT 800, 810 and 850 Maintenance and Service Manual Page 11-1
11
SECTION 11 – TROUBLESHOOTING AND
ELECTRICAL SYSTEM: 800 AND 810 GAS
ý
DANGER
• See General Warning on page 1-1.
ý
WARNING
• See General Warning on page 1-1.
GENERAL INFORMATION
Section 11 contains the information required to correctly troubleshoot the vehicle. A troubleshooting guide is
provided for general troubleshooting. For issues pertaining solely to the electrical system, proceed to Electri-
cal System on page 11-5.
In addition to troubleshooting, this section contains general information on the electrical system and the elec-
trical circuits of the system.
TROUBLESHOOTING GUIDE
The following troubleshooting guide will be helpful in identifying operating difficulties should they occur. The
guide includes the symptom, probable cause(s) and suggested checks. The procedures used in making these
checks can be found in the referenced sections of this maintenance and service manual.
TROUBLESHOOTING GUIDE
SYMPTOM POSSIBLE CAUSES REFER TO
Engine does not start easily. Spark plug is partially fouled or in poor
condition
Section 15 – Engine
Spark plug wire is damaged or loose Section 15 – Engine
Loose wire connection at ignition coil or
RPM limiter
Section 11 – Troubleshooting and Electrical
System: 800 and 810 Gas, Test
Procedures 14, 15, and 16
Intermittent ignition coil failure
Section 11 – Troubleshooting and Electrical
System: 800 and 810 Gas, Test
Procedures 14, 15, and 16
Low cylinder compression Section 15 – Engine
Water or dirt in the fuel system
and/or carburetor;
dirty or clogged fuel filter
Section 16 – Fuel System: Gasoline
Vehicle
Carburetor improperly adjusted
Section 16 – Fuel System: Gasoline
Vehicle
Starter/generator belt is slipping
Section 13 – Electrical Components: 800
and 810 Gasoline Vehicles
Belt Tension Adjustment on page 13-10
Troubleshooting Guide continued on next page...