Club Car IntelliTach XRT 1550, Maintenance And Service Manual

Page: 453 / 564

DIESEL ENGINE, MUFFLER, FUEL SYSTEM, AND CLUTCHES Air Intake System
2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual Page 13c-23
13C
AIR INTAKE SYSTEM
See General Warning, Section 1, Page 1-1.
AIR FILTER REPLACEMENT
The air filter should be inspected periodically and replaced when necessary. Filter changes should not exceed
the recommended interval.
See Periodic Service Schedule, Section 10a, Page 10a-1. More frequent ser-
vice may be required in extremely dirty operating environments. In the event of a loss of power, sluggish
acceleration, or a roughly running engine, service the air filter immediately.
CAUT ION
• Do not drill into the driver-side frame. Failure to heed this caution could damage the engine by
allowing excessive contamination or water to enter the air intake system.
Air Filter Removal
1. Release both canister tab locks (Figure 13c-24, Page 13c-23) .
2. Pull the canister cap away from the canister.
3. Remove the air filter cartridge. See following NOTE.
NOTE: The air filter cartridge is specifically designed for this engine. It only fits into the canister one way.
Use only direct replacement part (CCI P/N 102498601).
Air Filter Installation
1. Push the new filter cartridge onto the inside canister nozzle.
2. Place the canister cap, marked TOP, on the top center of the canister (Figure 13c-24, Page 13c-23) .
3. Secure the canister cap with both tab locks.
AIR CANISTER REMOVAL
1. Turn the key switch OFF and remove the key. Set the park brake. Place the Forward/Reverse handle in
NEUTRAL.
Figure 13c-24 Air Filter Cartridge