Club Car IntelliTach XRT 1550, Maintenance And Service Manual

Page: 144 / 564

PERIODIC MAINTENANCE: KAWASAKI GASOLINE & KUBOTA DIESEL POWERED VEHICLES Engine Oil
Page 10b-8 2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual
10B
NOTE: The normal oil pressure value stated in the Kawasaki engine manual is 35-45 psi at idle; however,
the remote filter design causes oil pressure to be 18 psi, which is normal for this type of oil circula-
tion design.
ENGINE OIL LEVEL CHECK
1. Remove the oil level dipstick from the oil filler tube and wipe oil from the dipstick (Figure 10b-6,
Page 10b-8 or Figure 10b-6, Page 10b-8) . See following CAUTION.
ý
CAUT ION
• Do not remove dipstick while engine is running.
2. Check oil level by fully inserting the dipstick into the tube and immediately removing it.
3. If the oil level is at or below the low level mark on the dipstick gauge, add oil until the level is between
low and full levels (safe level). See following CAUTION.
CAUT ION
• Do not fill oil above the full level mark. Doing so will result in decreased engine performance
or damage to the engine.
ENGINE OIL AND FILTER CHANGE
Engine oil and oil filter should be changed:
• Kawasaki gasoline engine after the first 10 hours of operation.
• Kubota diesel engine after the first 50 hours of operation.
After that, the oil should be changed every 100 hours of operation or annually, whichever comes first.
Figure 10b-6 Engine Oil Level Check –
Kawasaki Powered Gasoline Vehicles
Figure 10b-7 Engine Oil Level Check –
Diesel Vehicles
Full
Low
Level
Safe
Level
Level
1
2
3
Full
Low
Level
Safe
Level
Level
1
2 3