Club Car IntelliTach XRT 1550, Maintenance And Service Manual

Page: 405 / 564

HONDA GASOLINE ENGINE, MUFFLER, FUEL SYSTEM, AND CLUTCHES Fuel System
2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual Page 13b-15
13B
• After installing the fuel tank and adding fuel, carefully check all fuel lines and connections for
leaks. Repair leaks before the vehicle is returned to service.
17. Inspect each fuel line connection for leaks.
17.1. Check all clamps at the carburetor, fuel filters, fuel pump, and fuel tank for leaks.
17.2. Inspect each fuel line to ensure that the lines are not cracked, cut, or worn.
FUEL SHUT-OFF VALVE
See General Warning, Section 1, Page 1-1.
The fuel shut-off valve is located on top of the fuel tank (Figure 13b-7, Page 13b-13) . The fuel shut-off valve
should always be turned to the closed (OFF) position during vehicle storage, towing or trailering, and mainte-
nance and service
(Figure 13b-9, Page 13b-15) .
Fully Open Position
To open the valve fully, it must be turned approximately 120° from the closed (OFF) position (until it cannot be
turned any further)
(Figure 13b-10, Page 13b-15). If the valve becomes partially closed, the engine will be
starved for fuel and will not run properly (Figure 13b-11, Page 13b-15) .
Figure 13b-9 Closed Fuel Shut-Off Valve Figure 13b-10 Open Fuel Shut-Off Valve
Figure 13b-11 Incorrect Fuel Shut-Off Valve
CLOSED (OFF) POSITION
(SELECTOR IS ALIGNED
WITH OFF MARKINGS ON THE SIDES OF VALVE)
OFF OFF
VIEWED FROM SELECTOR
SIDE OF VALVE
FULL OPEN (ON)
POSITION
VIEWED FROM SELECTOR
SIDE OF VALVE
VIEWED FROM SELECTOR
SIDE OF VALVE
PARTIALLY CLOSED
POSITION