![Xerox ColorQube 9303 Series Service Manual Download Page 393](http://html1.mh-extra.com/html/xerox/colorqube-9303-series/colorqube-9303-series_service-manual_4672412393.webp)
February 2013
2-369
ColorQube® 9303 Family
91-523-00 to 91-558-00, 91-664-00 to 91-667-00, 91-
Status Indicator RAPs
Perform the printhead thermal tests,
dC335
. The tests complete successfully.
Y
N
Check the PEST fault history,
dC123
for marking unit heater faults (umbilicals, printheads
and ink melt reservoir). All marking unit heaters have failed.
Y
N
Go to
WD 9.8
,
WD 9.13
and
WD 9.20
,
WD 9.21
. Check the connections and wiring:
•
PJ101 and PJ301,
Printhead PWB
.
•
Disconnect the 8 pin AC printhead connector. Inspect the pins at both ends for
damage.
•
PJ401, PJ701,
Marking Unit Heater PWB
.
Install new components as necessary:
•
Marking unit heater PWB,
PL 92.10 Item 5
.
•
Printhead,
PL 91.20 Item 2
.
•
Power supply unit,
PL 1.15 Item 2
.
Refer to
WD 1.1
and
WD 9.8
, check the wiring between PJ4AC on the
Power Supply Unit
and PJ101 on the
Marking Unit Heater PWB
. The wiring is good.
Y
N
Repair the wiring,
REP 1.1
.
Check the +3.3V ESTAR distribution to the marking unit heater PWB, refer to the
01B
+3.3V ESTAR Distribution RAP. If the fault is still present, install new components as nec-
essary:
•
Marking unit heater PWB cable,
PL 92.10 Item 12
.
•
Marking unit heater PWB,
PL 92.10 Item 5
.
•
Marking unit driver PWB,
PL 92.10 Item 4
.
•
Power supply unit,
PL 1.15 Item 2
.
The error is intermittent. Refer to
GP 7
and check system grounding. Repair any ground issues
found.
NOTE: Calibration of the registration / preheat assembly,
dC625
is only required when:
•
The registration / preheat assembly is removed or replaced,
•
The horizontal transport assembly is removed or replaced.
Calibration of the registration / preheat assembly is NOT required when:
•
A printhead is replaced.
•
The IOD assembly is removed or replaced.
91-559-00 Marking Unit Components Out of Position RAP
The home position sensors are monitored as wiper or carriage motion is performed. This fault
occurs when carriage or wiper motion is requested and the sensors are not in the expected
state.
91-559-00 The carriage or wiper components are out of position for a requested action.
Initial Actions
WARNING
Ensure that the electricity to the machine is switched off while performing tasks that do
not need electricity. Refer to
GP 14
. Disconnect the power cord. Electricity can cause
death or injury. Moving parts can cause injury.
CAUTION
Do not handle or attempt to clean the wiper blade. Wiper blade contamination can damage the
printheads.
CAUTION
Do not touch the exposed face of the printheads. Surface contamination or minor damage can
destroy the printhead. Printheads must only be cleaned by a purge cycle.
CAUTION
Use care when opening the marking unit drawer when hot. Ink can spill from the ink reservoir
located at the back of the drawer if opened with too much force. Ink cross-color contamination
could also occur.
•
Check for damage or debris that restricts movement of the wiper.
•
Check the harness leading to the vertical and horizontal wiper drives and home sensor.
Refer to
GP 28
.
Procedure
Check the position of the carriages. The carriages are docked to the drum.
Y
N
Perform
dC967
Head to Drum Spacing Check.
dC967
runs successfully.
Y
N
Perform
ADJ 91.1
Printhead Attachment Check.
Perform
SCP 5
Final Actions.
Enter
dC330
. Run the following motors:
•
Code 91-023 HM vertical motion motor, MOT91-023,
PL 91.15 Item 12
.
•
Code 91-033 X axis drive motor upper, MOT91-033,
PL 91.20 Item 5
.
•
Code 91-034 X axis drive motor lower, MOT91-034,
PL 91.25 Item 5
.
•
Code 91-031 carriage docking motor, MOT91-031,
PL 91.10 Item 16
.
The motors run.
Y
N
Go to
WD 9.9
and
WD 9.11
. Check MOT91-023, MOT91-033 and MOT91-034.
Refer to:
•
GP 10
How to Check a Motor.
•
PJ303 (lower), PJ102 (upper) and PJ401,
Marking Unit Driver PWB
.
•
01J
+50V Distribution RAP
A
A
Summary of Contents for ColorQube 9303 Series
