Page 5-1
5
E
G
SECTION 5 - BODY AND TRIM
GENERAL INFORMATION
Each vehicle is equipped with an injection molded Armorflex
®
front and rear body. Use a mild soap or deter-
gent with a sponge or soft cloth for normal cleaning. Battery acid, fertilizers, tars, asphalt, creosote, paint, or
chewing gum should be removed immediately to prevent possible stains. Because the finish on the vehicle is
the same as the finish on today’s automobiles, commercial automotive cleaning products should be used.
• ONLY TRAINED MECHANICS SHOULD REPAIR OR SERVICE THIS VEHICLE. ANYONE DOING
EVEN SIMPLE REPAIRS OR SERVICE SHOULD HAVE KNOWLEDGE AND EXPERIENCE IN
GENERAL ELECTRICAL AND MECHANICAL REPAIR. FOLLOW ALL PROCEDURES EXACTLY
AND HEED ALL WARNINGS STATED IN THIS MANUAL.
• ALWAYS WEAR SAFETY GLASSES OR APPROVED EYE PROTECTION WHILE SERVICING THE
VEHICLE. WEAR A FULL FACE SHIELD WHEN WORKING WITH BATTERIES.
• ALWAYS WEAR A RESPIRATOR APPROVED FOR DUST AND MIST WHEN CUTTING, SANDING,
PAINTING, OR REPAIRING BODY PANELS.
• TURN KEY SWITCH OFF, PLACE FORWARD AND REVERSE LEVER IN THE NEUTRAL POSI-
TION, AND REMOVE KEY BEFORE SERVICING THE VEHICLE.
• DO NOT WEAR LOOSE CLOTHING. REMOVE JEWELRY SUCH AS RINGS, WATCHES, CHAINS,
ETC. BEFORE SERVICING VEHICLE.
• ALWAYS USE INSULATED TOOLS WHEN WORKING NEAR BATTERIES OR ELECTRICAL CON-
NECTIONS.
• MOVING PARTS! - DO NOT ATTEMPT TO SERVICE THE VEHICLE WITH THE ENGINE/MOTOR
RUNNING.
• HOT! - DO NOT ATTEMPT TO SERVICE HOT MOTOR, RESISTORS, ENGINE, OR EXHAUST
SYSTEM. FAILURE TO HEED THIS WARNING CAN RESULT IN SEVERE BURNS.
• GASOLINE VEHICLE: TO AVOID UNINTENTIONAL STARTING OF THE VEHICLE, DISCONNECT
THE SPARK PLUG WIRE FROM THE PLUG.
• ELECTRIC VEHICLE: TO AVOID UNINTENTIONAL STARTING OF THE VEHICLE, DISCONNECT
BATTERIES AS SHOWN IN FIGURE 22-5 OR FIGURE 22-6, PAGE 22-5. THEN DISCHARGE THE
CONTROLLER ON POWERDRIVE VEHICLES AS FOLLOWS:
- TURN THE KEY SWITCH TO ON AND PLACE THE FORWARD AND REVERSE LEVER IN THE
REVERSE POSITION.
- SLOWLY DEPRESS THE ACCELERATOR PEDAL AND KEEP IT DEPRESSED UNTIL THE
REVERSE WARNING BUZZER CAN NO LONGER BE HEARD. WHEN THE BUZZER STOPS
SOUNDING, THE CONTROLLER IS DISCHARGED.
• DO NOT USE DETERGENTS OR CLEANING SOLVENTS THAT CONTAIN AMMONIA, AROMATIC
SOLVENTS, OR ALKALI MATERIALS ON BODY PANELS OR SEATS.
• DO NOT ALLOW BATTERY ACID TO DRIP ON BODY PANELS. BATTERY ACID WILL CAUSE
PERMANENT BLEMISHES. WASH ACID OFF BODY PANELS IMMEDIATELY.
WARNING
CAUTION
Summary of Contents for 1996 DS Golf Car Gasoline
