![background image](http://html1.mh-extra.com/html/club-car/1996-ds-golf-car-gasoline/1996-ds-golf-car-gasoline_service-manual_2626737381.webp)
Page 20-31
E
20B
3. Slide center dash panel up the steering column by snapping out the top and then rotating the panel out
and up. There is sufficient slack in the wiring to allow for this.
4. Disconnect the 18 gauge red and orange wires from reverse buzzer.
5. Remove the two screws from the reverse buzzer.
6. Remove the reverse buzzer from the center dash panel.
Installing the Reverse Buzzer
Install the reverse buzzer in the reverse order of removal.
THE SOLENOID
The solenoid is located on the passenger’s side fender well behind the battery compartment. The solenoid
has two sets of posts; two 5/16 inch posts (power contact posts) and two small No. 10 posts (activating coil
posts).
Testing the Solenoid
See Test Procedure 7, Page 20-16.
Removing the Solenoid
1. Disconnect batteries (Figure 20-1, Page 20-2).
2. Discharge the controller (See instructions in Warning Box on Page 20-25).
3. Disconnect all wires from solenoid. Remove resistor assembly and diode assembly.
• BENDING THE TOP RIGHT CORNER OF THE CENTER DASH INWARD WHILE REMOVING IT
WILL PREVENT THE CONTACTS ON THE REAR OF THE KEY SWITCH FROM TOUCHING THE
METAL FRAME AROUND THE DASH.
• TURN THE KEY TO OFF AND REMOVE THE KEY, PUT THE FORWARD AND REVERSE SWITCH
IN NEUTRAL, DISCONNECT THE BATTERY CABLES AS SHOWN IN FIGURE 20-1, PAGE 20-2,
AND DISCHARGE CONTROLLER (SEE WARNING ON PAGE 20-1). FAILURE TO DO SO MAY
CAUSE THE VEHICLE TO RUN OVER YOU, RESULTING IN SEVERE INJURY OR DEATH!
• WHEN MAKING ELECTRICAL TESTS OR REPAIRS, ALWAYS:
- WEAR SAFETY GLASSES OR APPROVED EYE PROTECTION.
- REMOVE THE KEY.
- PUT THE FORWARD AND REVERSE SWITCH IN NEUTRAL.
- DISCONNECT THE BATTERIES AS SHOWN (FIGURE 20-1, PAGE 20-2).
• FOLLOW ALL PROCEDURES EXACTLY AS INSTRUCTED.
• SEE THE SAFETY WARNINGS ON PAGE 20-1.
NOTE
NOTE
DANGER
WARNING
Summary of Contents for 1996 DS Golf Car Gasoline
