![background image](http://html1.mh-extra.com/html/club-car/1996-ds-golf-car-gasoline/1996-ds-golf-car-gasoline_service-manual_2626737025.webp)
Page 3-11
G
E
3
2. Drain carburetor and seal the fuel tank.
2.1. Place the Forward and Reverse Lever in the NEUTRAL position and the neutral lock-out cam in
the SERVICE position. Disconnect the fuel line from the fuel pump and run the engine until fuel
remaining in the carburetor and fuel lines is used up and the engine stalls. Return the neutral
lock-out cam to OPERATE position.
2.2. Loosen (do not remove) the carburetor drain screw and drain fuel remaining in bowl into a small
container, then pour the fuel from the container into vehicle fuel tank.
2.3. Reconnect fuel line to fuel pump.
2.4. Disconnect fuel vent line from fuel tank vent nipple.
2.5. Plug the fuel tank vent nipple so that it is air tight. We recommend using a slip-on vinyl cap.
3. To protect the engine, remove the spark plug and pour 1/2 ounce of SAE 10 weight oil into the engine
through the spark plug hole. Rotate the engine crank shaft several times and then re-install the spark
plug.
4. Increase tire pressure to 20 psi.
5. Grease front suspension and do all quarterly periodic lubrication (See Periodic Lubrication Sched-
ule, Section 4, Page 4-2).
6. Thoroughly clean front body, rear body, seats, engine compartment, and underside of vehicle.
7. Do not latch the park brake. Block tires to prevent the vehicle from rolling.
• GASOLINE - FLAMMABLE! EXPLOSIVE! DO NOT SMOKE. KEEP SPARKS AND FLAMES
AWAY FROM THE AREA OF THE VEHICLE.
• NEVER ATTEMPT TO DRAIN GASOLINE WHEN THE ENGINE IS HOT OR WHILE IT IS RUN-
NING. BE SURE TO CLEAN UP ANY SPILLED GASOLINE BEFORE OPERATING THE VEHICLE.
• STORE GASOLINE IN AN APPROVED GASOLINE CONTAINER ONLY. STORE IN A WELL-VEN-
TILATED AREA AWAY FROM SPARKS, OPEN FLAME, HEATERS, OR HEAT SOURCES.
• DO NOT SERVICE, REPAIR, OR OPERATE IN AN ENCLOSED AREA WITHOUT PROPER VEN-
TILATION. THE ENGINE PRODUCES CARBON MONOXIDE WHICH IS AN ODORLESS, DEADLY
POISON.
• KEEP GASOLINE OUT OF THE REACH OF CHILDREN.
• DO NOT SIPHON GASOLINE FROM THE VEHICLE.
• DO NOT ATTEMPT TO CHARGE A BATTERY IF IT IS FROZEN OR IF THE CASE IS BULGED.
DISCARD THE BATTERY. FROZEN BATTERIES CAN EXPLODE.
• BATTERIES IN A LOW STATE OF CHARGE WILL FREEZE AT LOW TEMPERATURES.
• TURN THE KEY SWITCH TO OFF, REMOVE THE KEY, AND LEAVE THE FORWARD AND
REVERSE LEVER IN THE NEUTRAL POSITION DURING STORAGE. THIS IS TO PREVENT
UNINTENTIONAL STARTING OF THE VEHICLE.
DANGER
WARNING
CAUTION
WARNING
Summary of Contents for 1996 DS Golf Car Gasoline
