Page 14-7
G
14
2. Position the carburetor with the drain screw (11) over a catch basin (Figure 14-7).
3. Turn the carburetor bowl drain screw counterclockwise two or three turns and drain all of the fuel from
the bowl into the catch basin (Figure 14-7). Tighten the drain screw to 6-13 in.lbs. (0.7/1.5 N-m).
4. Mark the body of the carburetor and the carburetor fuel bowl with an indelible ink marker so that, after
removal, the bowl can be installed again in the same position (Figure 14-7).
5. Remove the carburetor fuel bowl retaining screw and washer (12), then remove the fuel bowl (10) and
clean it with a nonflammable solvent (Figure 14-7).
6. Remove the main jet (8) from the carburetor body and discard it (Figure 14-7).
• MAKE SURE THAT THE FUEL BOWL GASKET (9) REMAINS PROPERLY SEATED IN THE CAR-
BURETOR BODY WHEN THE FUEL BOWL IS REMOVED.
• DURING NORMAL OPERATION, THE FUEL BOWL RETAINS THE FLOAT PIVOT PIN (6). MAKE
SURE THAT THE FLOAT PIVOT PIN DOES NOT FALL OUT OF THE CARBURETOR BODY
AFTER THE FUEL BOWL IS REMOVED.
• MAKE SURE THAT THE FUEL NOZZLE (ITEM 7) DOES NOT FALL OUT OF THE CARBURETOR
BODY AFTER REMOVAL OF THE MAIN JET. THIS IS BEST ACCOMPLISHED BY POSITIONING
THE CARBURETOR UPSIDE DOWN DURING MAIN JET REMOVAL.
FIGURE 14-7
NOTE
NOTE
DRAIN CARBURETOR OVER
A CATCH BASIN BY TURNING
BOWL DRAIN SCREW (10)
COUNTERCLOCKWISE
2 TO 3 TURNS
STEPS 2 AND 3
STEP 4
A
MARK CARBURETOR
AND CORRESPONDING
POSITION OF FUEL BOWL
B
CHECK FOR
COIL LOCATED
IN GROOVE ABOVE
BOTH EARS
CHECK FOR
SPRING SEATED
IN RECESS OF
FLOAT BODY
IF
SPRING LOOKS
LIKE THIS...
OR THIS...
THEN
ADJUST
SPRING TO LOOK
LIKE THIS
BY...
C
D
HOLDING FLOAT FIRMLY...AND...
ROTATING VALVE COUNTERCLOCKWISE
TO SEAT SPRING IN SEAT OF FLOAT BOWL
CAUTION: DO NOT REMOVE VALVE/SPRING
FROM FLOAT, TO DO SO WILL DAMAGE SPRING
1
2
3
4
5
7
8
9
6
10
11
12
Summary of Contents for 1996 DS Golf Car Gasoline
