Page 12-9
G
12
TESTING THE ENGINE IGNITION CIRCUIT
Use the chart below (Figure 12-14) as a starting point for troubleshooting problems with the engine ignition
circuit .
TESTING THE ENGINE KILL CIRCUIT
Use the chart page 12-10 (Figure 12-15) and the chart on page 12-11 (Figure 12-16) as starting points for
troubleshooting problems with the engine kill circuit. See DANGER and WARNING at top of page 12-10.
• DO NOT OPERATE GASOLINE VEHICLE IN AN ENCLOSED AREA WITHOUT PROPER VENTI-
LATION. ENGINE PRODUCES CARBON MONOXIDE WHICH IS AN ODORLESS, DEADLY POI-
SON.
• WHEN MAKING ELECTRICAL TESTS OR REPAIRS, ALWAYS:
- WEAR SAFETY GLASSES OR APPROVED EYE PROTECTION.
- REMOVE THE KEY.
- PUT THE FORWARD AND REVERSE SWITCH IN NEUTRAL.
- DISCONNECT THE BATTERY AS SHOWN (FIGURE 12-1, PAGE 12-2).
• FOLLOW ALL PROCEDURES EXACTLY AS INSTRUCTED.
• SEE THE SAFETY WARNINGS ON PAGE 12-1.
FIGURE 12-14
DANGER
WARNING
IGNITION GAS TEST
GOOD
REPLACE SPARK PLUG
ENGINE CRANKS -
CAR WILL NOT RUN
IGNITION GAP TEST
(TEST PROCEDURE 11)
CHECK FUEL SYSTEM
(SEE SECTION 14)
CHECK
COMPRESSION
(SEE SECTION 13, PAGE 13-50)
IGNITION GAP TEST
NOT GOOD
DISCONNECT
ENGINE KILL WIRE
GOOD SPARK
NO SPARK
CHECK IGNITER
(TEST PROCEDURE 12)
CHECK RPM LIMITER
(TEST PROCEDURE 14)
CHECK PLUG GAP
(SEE SECTION 13, PAGE 13-7)
CHECK COIL
(TEST PROCEDURE 14)
ENGINE RUNS
ENGINE DOES NOT RUN
CHECK FOR
GROUNDED WIRE
(TEST PROCEDURE 8)
REPAIR OR REPLACE
Summary of Contents for 1996 DS Golf Car Gasoline
