AIRCRAFT
DA 42 NG AMM
Flight Controls
Doc # 7.02.15
Rev. 4
27-20-00
Page 207
15 Mar 2018
C. Install the Rudder Control Cables (Front Cables)
Detail Steps/Work Items
Key Items/References
WARNING:
ONLY TRAINED AND AUTHORIZED PERSONS SHOULD INSTALL
CABLE EYE-ENDS. IF THE EYE-ENDS ARE NOT INSTALLED
CORRECTLY, THE RUDDER CONTROLS CAN FAIL. THIS CAN
CAUSE DEATH OR INJURY TO PERSONNEL.
Note:
Install eye ends in accordance with FAA AC 43.13-1B, Chapter 7, Section 8.
Note:
To make the work easier, install an eye end on one end of the cable before you
install it in the airplane.
(1)
Install one new eye end to the cable before you
install it in the airplane:
S
Use cables to specification LN9374 or ISO
2020 or MIL-DTL-83420, streched to 60 %
MBS.
S
Make the eye-end using Locoloc thimbles
and Nico-Press clamps appropriate to the
installed 3.2 mm (1/8") diameter steel
cables.
S
Inspect the cable eye end for correct
assembly.
S
If necessary for your Airworthiness
Authority, send a sample eye end for proof
test.
Inspect cable swages with go/no go
gauge for 1/8 in Nicopress oval sleeve in
accordance with FAA AC 43.13-1B,
Chapter 7, Section 8.
(2)
Push the control cable through the Teflon tubes
from the rear.
Refer to Figure 3.
(3)
Make sure the cable is in the correct position on
the pulley (for the outer cables only).
(4)
Push the cable through the “S” shaped tube on
the rudder pedal assembly.
Summary of Contents for DA 42 NG
