Arctic Cat 650 Twin2004, Руководство по обслуживанию

Страница: 13 / 210

2-4
3. Remove the vent plugs; then (if necessary) fill the
battery with distilled water to the upper level
indicated on the battery.
4. Trickle charge the battery at 1.4 amps for 10
hours.
5. After charging, check fluid level and fill with dis-
tilled water as necessary; then install vent plugs.
6. Place the battery into position in the ATV and
secure with the hold-down bracket.
7. Attach the vent tube and check the vent tube to
make sure it is not crimped or obstructed in any
way and that it is properly routed through and
secured to the frame.
8. Connect cables to the proper terminals: positive
cable to the positive terminal (+) and negative
cable to the negative terminal (-). Connect the neg-
ative cable last.
AF733D
FUSES
The fuses are incorporated into the Power Distribution
Module which is located on the upper frame behind
the right front fender.
If there is any type of electrical system failure, always
check the fuses first.

NOTE: To remove the fuse, compress the locking
tabs on either side of the fuse cover and lift off.
KX053A
KX202A
Air Cleaner/Filter
The air filter inside the air filter housing must be kept
clean to provide good engine power and gas mileage.
If the ATV is used under normal conditions, service
the filter at the intervals specified. If operated in dusty,
wet, or muddy conditions, inspect and service the filter
more frequently. Use the following procedure to
remove the filter and inspect and/or clean it.
CLEANING AND INSPECTING FILTER
1. Remove the seat; then remove the screws securing
the storage compartment cover housing and
remove the housing and cover.
! CAUTION
Never exceed the standard charging rate.
! CAUTION
Before installing the battery, make sure the
ignition switch is in the OFF position.
! CAUTION
Connecting cables in reverse (positive to
negative and negative to positive) can cause
serious damage to the electrical system.
! CAUTION
Always replace a blown fuse with a fuse of the
same type and rating.
! CAUTION
Failure to inspect the air filter frequently if the
vehicle is used in dusty, wet, or muddy
conditions can damage the engine.