21-1
Troubleshooting
Engine Does Not Starter is Hard to Start
………………………………………………
21-1
Engine Lacks Power
………………………………………………………………………
21-2
Poor Performance(At Low and Idle Speeds)
……………………………………………
21-3
Poor Performance (At High speed)
………………………………………………………
21-4
Poor Handling
………………………………………………………………………………
21-4
21. Troubleshooting
Engine Doesn’t Start or is Hard to Start
1. Check fuel flow to carburetor.
Not reaching
Fuel tank empty.
carburetor.
Clogged fuel tube or fuel filter.
Sticking float valve.
Clogged fuel tank breather.
2. Perform a spark test.
Weak or no
Faulty spark plugs.
Stark.
Fouled spark plugs.
Faulty CDI unit.
Broken or shorted high tension wires.
Faulty pulse generator.
Faulty main switch.
3. Test cylinder compression.
Low compression.
Low speed of starter crank.
Incorrect valve clearance.
Faulty valve seat.
Worn cylinder and piston rings.
Seized valve.
Improper valve timing.
4. Start by following normal
Engine starts
Improper chock valve operation.
procedure.
but stops.
Improper chock cable free play.
Carburetor incorrectly adjusted.
Improper ignition timing.
(Faulty CDI unit or pulse generator.)
Fuel contaminated.
5. Remove and inspect spark plug.
Wet plug.
Carburetor flooded.
Throttle valve open.
Choke closed.
Air cleaner dirty.
6. Close the choke and start engine
again
21
Reaching carburetor.
Good spark.
Compression normal.
Engine does not start.
Dry plug.
Summary of Contents for DAYSTAR -
