Club Car CARRYALL 272, Руководство по техническому обслуживанию и ремонту

Страница: 246 / 312

FUEL SYSTEM Fuel Tank
Page 14-22 2006-2010 Turf/Carryall 272/472 and XRT 1200/1200 SE Maintenance and Service Manual
14
FUEL TANK
See General Warning, Section 1, Page 1-1.
ý
WARNING
• If the fuel tank is damaged, replace it. Do not attempt to repair it. See the following tank
removal and disposal procedure.
CAUT ION
• Add only unleaded gasoline to the tank. Do not put oil into the fuel tank.
FUEL TANK REMOVAL
1. Turn the key switch to OFF and remove the key. Place the Forward/Reverse handle in the NEUTRAL
position. Chock the wheels.
2. Turn fuel shut-off valve to the closed (OFF) position (Figure 14-20, Page 14-28 or Figure 14-21,
Page 14-28) .
3. Run the engine until fuel remaining in the carburetor, fuel pump and fuel lines is used up and the engine
stalls.
4. Disconnect battery and spark plug wire(s). See Disconnecting The Battery on page 1-3.
5. Remove the four bolts (8), eight washers (9) and four locknuts (10) from the seat support and remove the
two armrests (11 and 12) from the vehicle. See Figure 4-3, Section 4, Page 4-8.
6. Carefully remove and rotate the seat support (7) 90° clockwise and allow it to rest on the vehicle body
(Figure 14-14, Page 14-22) . See following NOTE.
NOTE: It is not necessary to remove the park brake cable or differential lock cable to service or remove the
fuel tank.
7. Loosen, but do not remove, the carburetor drain screw (11) (Figure 14-3, Page 14-5) and drain fuel
remaining in the carburetor bowl into an approved container.
8. Use a siphon with a suction device and siphon all fuel out of the tank and into an approved container. See
following DANGER and WARNING.
Figure 14-14 Seat Support Removal
7