Club Car CARRYALL 272, Руководство по техническому обслуживанию и ремонту

Страница: 212 / 312

ELECTRICAL COMPONENTS: FE400, KEY-START ENGINE Battery
Page 12-42 2006-2010 Turf/Carryall 272/472 and XRT 1200/1200 SE Maintenance and Service Manual
12
body as illustrated (Figure 12-46, Page 12-42) . See following NOTE.
NOTE: It is not necessary to remove the park brake cable or differential lock cable to service or remove the
battery.
4. Carryall 472/XRT 1200 SE:
4.1. Remove the rear seat.
4.2. Remove the choke cable and bracket from the air filter box.
5. Remove the battery hold-down clamp from the battery and remove. See following WARNING .
ý
WARNING
• Keep the battery in an upright position to prevent electrolyte leakage. Tipping the battery
beyond a 45° angle in any direction can allow a small amount of electrolyte to leak out of the
vent hole. Do not exceed this 45° angle when lifting, carrying or installing battery. The battery
acid could cause severe personal injury when accidentally coming in contact with the skin or
eyes, and could damage clothing.
Charging the Battery
See General Warning, Section 1, Page 1-1 and DANGER on page 12-39.
1. Charge the battery using an automotive type 12-volt battery charger. Follow all warnings and procedures
supplied by the battery charger manufacturer.
2. Attach the charger, positive (+) cable to the positive (+), and negative (–) cable to the negative (–) battery
post.
3. The battery may be charged with a slow charge (3-10 amps) or a fast charge (20-30 amps). Charge until
the specific gravity reaches 1.250. See following WARNING.
Figure 12-46 Turf 272/Carryall 272/XRT 1200 Battery Removal
7