Club Car 2005 precendent, Maintenance And Service

Page: 197 / 256

FUEL SYSTEM Fuel Tank
2005 Precedent Gasoline Golf Car Maintenance and Service Manual Page 14-19
14
ý
WARNING
• Make sure the key switch is off before disconnecting wiring.
9. Remove the vent tube (14) and fuel line (9) from the fuel tank (Figure 14-8, Page 14-13)
10. Remove two screws (3) holding the forward end of the fuel tank hold-down (2). Lift up on the forward end
of the hold-down and release the rear end from the fuel bracket.
11. Lift the fuel tank (1) out of the vehicle.
FUEL TANK DISPOSAL
1. Remove the cap from the tank. Thoroughly rinse the cap with water. The cap may be discarded or kept
as a spare.
2. In a well-ventilated area, flush the fuel tank with water to remove any remaining fuel.
3. In a well-ventilated area, set the tank upside down so that the water can drain out of it. To make sure that
the tank dries completely, allow the tank to sit for 24 hours. See following CAUTION .
ý
CAUTION
• Dispose of wastewater and fuel tank in accordance with local, state, and federal laws and
ordinances.
FUEL TANK STORAGE
1. Remove the cap from the tank and thoroughly rinse it with water.
2. In a well-ventilated area, flush the fuel tank with water to remove any remaining fuel.
3. In a well-ventilated area, set the tank upside down so that the water can drain out of it. To make sure that
the tank dries completely, allow the tank to sit for 24 hours.
4. Store the tank upside down, with the cap installed, in a well-ventilated area.
Figure 14-11 Fuel Level Sending Unit
TANK
CONNECTION
BLACK
WIRE TO
GROUND
ORANGE
WIRE
WITH
SENDING UNIT
BLACK
WIRE TO
GROUND
WITHOUT
SENDING UNIT