Triumph Tiger Explorer XR 2016, Service Manual

Page: 9 / 750

CAUTION
courses etc., dispose of used oil sensibly. If in doubt contact your local authority.
Burning of used engine oil in small space heaters or boilers can be recommended only for units of approved
design. If in doubt, check with the appropriate local authority and/or manufacturer of the approved appliance.
Dispose of used oil and used filters through authorised waste disposal contractors, to licensed waste disposal
sites, or to the waste oil reclamation trade. If in doubt, contact your local authority for advice on disposal
facilities.
Brakes
WARNING
Brake fluid is hygroscopic which means it will absorb moisture from the air. Any absorbed moisture will
greatly reduce the boiling point of the brake fluid causing a reduction in braking efficiency.
Replace brake fluid in line with the routine maintenance schedule. A dangerous riding condition could result if
this important maintenance item is neglected!
Do not spill brake fluid onto any area of the bodywork as this will damage any painted or plastic surface.
Always use new brake fluid from a sealed container and never use fluid from an unsealed container or from
one that has been previously opened.
Do not mix different brands of fluid. Check for fluid leakage around brake fittings, seals and joints.
Check regularly for brake hose damage.
FAILURE TO OBSERVE ANY OF THE ABOVE WARNINGS MAY REDUCE BRAKING EFFICIENCY
LEADING TO AN ACCIDENT.
WARNING
If there has been an appreciable drop in the level of the fluid in either brake fluid reservoir, consult your
authorised Triumph dealer for advice before riding.
If the brake lever or pedal feels soft when it is applied, or if the lever/pedal travel becomes excessive, there
may be air in the brake lines or the brake may be defective.
It is dangerous to operate the motorcycle under such conditions and remedial action must be taken by your
authorised Triumph dealer before riding the motorcycle.
Failure to take remedial action may reduce braking efficiency leading to an accident.
WARNING
Use only DOT 4 specification brake fluid as listed in the General Information section of this manual. The use
of brake fluids other than those DOT 4 fluids listed in the General Information section may reduce the
efficiency of the braking system leading to an accident.
Failure to change the brake fluid at the interval specified in the routine maintenance schedule may reduce
braking efficiency resulting in an accident.
WARNING
Never use mineral-based grease in any part of the braking system or in any area where contact with the
braking system is possible. Mineral-based grease will damage the hydraulic seals in the calipers and master
cylinders.
Damage caused by contact with mineral-based grease may reduce braking efficiency resulting in an
accident.
Tiger Explorer XR Series
5 of 746
GENERAL INFORMATION