Centaur 2001 950, Руководство по обслуживанию, Страница: 91 / 450

Electrical System Centaur Service Manual
ES-6
Ontario Drive & Gear Limited www.centaur8x8.ca
(519) 662-2840 FAX (519) 662-2421
ES-7
Centaur Service Manual Electrical System
Ontario Drive & Gear Limited www.centaur8x8.ca
(519) 662-2840 FAX (519) 662-2421
Electrical System Centaur Service Manual
Charging the Battery
If the battery loses its electrical charge, remove the battery from the Centaur and recharge
it with a 12 volt battery charger at the rate of 10-12 amps maximum. The battery should
remain on charge until the specific gravity reaches 1.265 on a hydrometer. Re-install the
battery in the vehicle and try to start the engine. If the battery fails to perform properly,
have it tested by a battery service dealer. Replace a defective battery with Part No. 613-100
for gas powered Centaurs or Part No. 613-101 for diesel powered Centaurs.
Ventilate area when charging. Keep away from spark, heat, cigarettes or open
flame.
Cleaning the Battery Terminals and Cable Connections
Clean the battery terminals and cable connections every 100 hours. Remove the black
NEGATIVE (-) cables first. Make sure you reconnect the NEGATIVE (-) cables to the
NEGATIVE (-) post and the red POSITIVE (+) cables to the POSITIVE (+) posts. Damage
to the electrical system will occur if the cables are reversed.
Cleaning the Battery
Clean the top of the battery every 300 hours with a mixture of baking soda and water. Before
cleaning the battery, remove it from the vehicle and make sure the vents are in place. Soak
a cloth in the soda/water mixture and scrub the top of the battery. After the foaming has
stopped, flush with clean water and dry with a clean cloth.
Electrical System Fuses
The Centaur is equipped with push-in type automotive fuses. The fuses protect the electrical
circuits of the vehicle. They are located in the fuse block, under the dash. Replace any
blown fuses. Inspection of the electrical circuit is necessary if a fuse blows repeatedly.
Battery fluid contains sulphuric acid. If battery fluid comes in contact with skin or
eyes, flush thoroughly with water. If swallowed, call physician or poison control centre
immediately. KEEP AWAY FROM CHILDREN. Serious personal injury can occur.
Always wear rubber gloves and safety glasses when servicing the battery.
Batteries can explode and cause serious personal injury if exposed to flame or sparks.
Never smoke while servicing the battery.
All models are equipped with a 12 volt,
electrolyte type battery. The battery is
located in the engine compartment, on
the left side of the engine.
Checking Fluid Level
Initially fill the battery to cover plates.
After charge is complete and battery is warm,fill to the correct level.