Club Car CARRYALL 272, Maintenance And Service Manual

Page: 251 / 312

FUEL SYSTEM Fuel Lines
2006-2010 Turf/Carryall 272/472 and XRT 1200/1200 SE Maintenance and Service Manual Page 14-27
14
12. Allow the engine to run for a few minutes to ensure that the fuel lines are full of fuel.
13. Inspect each fuel line for leaks.
13.1. Check all of the fuel line clamps at the carburetor, fuel filters, fuel pump and fuel tank for leaks.
13.2. Inspect each fuel line to ensure that the lines are not cracked, cut or worn.
14. Turn the key switch to OFF.
FUEL LINES
See General Warning, Section 1, Page 1-1.
The fuel lines must be properly routed, and all hose clamps must be tight. The fuel lines should be kept clean.
See following WARNING.
ý
WARNING
• Make sure fuel lines are the right length and are properly routed. Failure to heed this warning
could result in damage to fuel lines and fire.
Fuel line no. 1 runs directly from the fuel tank to the primary fuel filter (17). Arrow indicates flow (Figure 14-16,
Page 14-24 or Figure 14-17, Page 14-25) .
Fuel line no. 2 runs directly from the primary fuel filter (17) to the fuel inlet of the fuel pump (18).
Fuel line no. 3 runs directly from the fuel outlet of the fuel pump (18) to the secondary fuel filter (22), if
equipped. Arrow indicates flow. If vehicle is not equipped with secondary fuel filter (22), fuel line no. 3 runs
directly to the carburetor.
For vehicles equipped with a secondary fuel filter only: Fuel line no. 4 runs from the outlet of the second-
ary fuel filter (22) to the carburetor. Arrow indicates flow.
A screw band clamp should be used at the carburetor.
Figure 14-18 Turf 272/Carryall 272/XRT 1200
Fuel System
Figure 14-19 Carryall 472/XRT 1200 SE Fuel System
1. Vent Tube* 2. To Carburetor 3. Vent 4. Fuel Shut-off Valve 5.
Fuel Tank
*Vehicle without carbon canister shown.
1. Vent Tube 2. Fuel Tank 3. Vent 4. Fuel Shut-off Valve 5. Fuel
Pump (under rear seat) 6. Fuel Filter (under rear seat)
1
4
5
3
2
1
3
4
5
6
2
A
A