FUEL INJECTION SYSTEM
8-38
3
Wire harness continuity.
Open or short circuit
→
Re-
place the wire harness.
Between intake air pressure
sensor coupler and ECU
coupler.
black/blue–black/blue
pink/white–pink/white
blue–blue
Set the main switch to “ON”.
Fault code number is not dis-
played
→
Service is finished.
Fault code number is dis-
played
→
Go to item 4.
4
Installed condition of intake
air pressure sensor.
Check for looseness or
pinching.
Improperly installed sensor
→
Reinstall or replace the
sensor.
Set the main switch to “ON”.
Fault code number is not dis-
played
→
Service is finished.
Fault code number is dis-
played
→
Go to item 5.
5
Defective intake air pressure
sensor.
Execute the diagnostic
mode. (Code No. d:03)
When engine is stopped:
Atmospheric pressure at the
current altitude and weather
conditions is indicated.
At sea level: Approx. 101 kPa
1000 m above sea level: Ap-
prox. 90 kPa
2000 m above sea level: Ap-
prox. 80 kPa
3000 m above sea level: Ap-
prox. 70 kPa
When engine is cranking:
Make sure that the indication
value changes.
The value does not change
when engine is cranking.
→
Replace the intake air pres-
sure sensor.
Refer to “CHECKING THE
INTAKE AIR PRESSURE
SENSOR” on page 8-154.
Set the main switch to “ON”.
Fault code number is not dis-
played
→
Service is finished.
Fault code number is dis-
played
→
Go to item 6.
6
Malfunction in ECU.
Replace the ECU.
Fault code No.
14
Item
Intake air pressure sensor: hose system malfunction (clogged
or detached hose).
Fail-safe system
Able to start engine
Able to drive vehicle
Diagnostic code No.
d:03
Meter display
Displays the intake air pressure.
Fault code No.
13
Item
Intake air pressure sensor: open or short circuit detected.
Summary of Contents for XT1200Z(Z) 2010
