FUEL INJECTION SYSTEM
8-39
Procedure
Set the engine stop switch to “
”, and then operate the throttle
while pushing the start switch “
”. (If the display value changes,
the performance is OK.)
Item
Probable cause of mal-
function and check
Maintenance job
Confirmation of service
completion
1
Condition of intake air pres-
sure sensor hose.
Check the intake air pressure
sensor hose condition.
Clogged or detached hose
→
Repair or replace the sen-
sor hose.
Start the engine and let it idle
for approximately 5 seconds.
Fault code number is not dis-
played
→
Service is finished.
Fault code number is dis-
played
→
Proceed to the
next item.
2
Defective intake air pressure
sensor.
Execute the diagnostic
mode. (Code No. d:03)
When engine is stopped:
Atmospheric pressure at the
current altitude and weather
conditions is indicated.
At sea level: Approx. 101 kPa
1000 m above sea level: Ap-
prox. 90 kPa
2000 m above sea level: Ap-
prox. 80 kPa
3000 m above sea level: Ap-
prox. 70 kPa
When engine is cranking:
Make sure that the indication
value changes.
The value does not change
when engine is cranking.
→
Replace the intake air pres-
sure sensor.
Refer to “CHECKING THE
INTAKE AIR PRESSURE
SENSOR” on page 8-154.
Fault code No.
15
Item
Throttle position sensor: open or short circuit detected.
Fail-safe system
Able/Unable to start engine
Able/Unable to drive vehicle
Diagnostic code No.
d:01, d:13
d:01
Meter display
Throttle position sensor signal 1
• 9–20 (fully closed position)
Procedure
• Check with throttle valves fully closed.
Fault code No.
14
Item
Intake air pressure sensor: hose system malfunction (clogged
or detached hose).
Summary of Contents for XT1200Z(Z) 2010
