ABS (ANTI-LOCK BRAKE SYSTEM)
8-102
16
Rear wheel sensor circuit is short-cir-
cuited.
• Rear wheel sensor circuit
• Wire harness (ABS circuit)
• Connection of the rear wheel sensor cou-
pler and ABS ECU coupler
• Rear wheel sensor
17
Missing pulses detected in the front
wheel sensor signal.
• Front wheel sensor rotor
• Front wheel sensor housing
• Front wheel
18
Missing pulses detected in the rear
wheel sensor signal.
• Rear wheel sensor rotor
• Rear wheel sensor housing
• Rear wheel
21
Hydraulic unit solenoid circuit is open
or short-circuited.
• Hydraulic unit assembly
22
Start switch signal is not received prop-
erly (start switch circuit or start switch
monitor circuit).
• Wire harness
• Connection of the starter relay coupler,
ABS ECU coupler, and right handlebar
switch coupler.
31
Solenoid relay is defective.
Power is not supplied to the solenoid
relay.
• Battery voltage
• Hydraulic unit assembly
33
ABS motor is defective.
Power is not supplied to the ABS mo-
tor.
• Battery voltage
• ABS motor fuse
• Wire harness (ABS circuit)
• Connection of the ABS ECU coupler and
starter relay coupler
• Hydraulic unit assembly
34
Hydraulic unit ABS motor is short-cir-
cuited.
• Hydraulic unit assembly
41
Front wheel will not recover from the
locking tendency even though the sig-
nal is continuously transmitted from the
ABS ECU to release the hydraulic
pressure (when the battery voltage is
normal).
• Brake dragging
• Brake fluid
• Hydraulic unit operation tests
• Front wheel brake lines
• Hydraulic unit assembly
42
Rear wheel will not recover from the
locking tendency even though the sig-
nal is continuously transmitted from the
ABS ECU to release the hydraulic
pressure (when the battery voltage is
normal).
• Brake dragging
• Brake fluid
• Hydraulic unit operation tests
• Rear wheel brake lines
• Hydraulic unit assembly
51
Power voltage is too high.
• Battery voltage
• Refer to “CHARGING SYSTEM” on page
53
Power voltage is too low.
• Battery voltage
• Connection of the ABS ECU coupler
• Wire harness
• Refer to “CHARGING SYSTEM” on page
56
ABS ECU has internal malfunction.
• Hydraulic unit assembly
Fault
code No.
Symptom
Check point
Summary of Contents for XT1200Z(Z) 2010
