ABS (ANTI-LOCK BRAKE SYSTEM)
8-113
Fault code No.
18
Symptom
Missing pulses detected in the rear wheel sen-
sor signal.
Order Item/components and probable
cause
Check or maintenance job
Reinstatement
confirmation
method
1
Installed condition of wheel bearings,
axle, sensor housing, and sensor ro-
tor.
Check the components for loose-
ness, distortion, and bends.
Refer to “CHECKING THE REAR
WHEEL” on page 4-32.
• Set the main
switch to “ON”
and check
that the ABS
warning light
comes on for
2 seconds,
then goes off.
• Perform a tri-
al run at a
constant
speed of 30
km/h and
check that the
ABS warning
light does not
come on.
2
Foreign material inside sensor hous-
ing.
Check the interior of the sensor
housing and the surface of the
sensor rotor for foreign material,
such as metal particles. Clean
the sensor housing and sensor
rotor if necessary.
Refer to “MAINTENANCE OF
THE REAR WHEEL SENSOR
AND SENSOR ROTOR” on page
4-33.
3
Defective sensor rotor.
• Check the surface of the sensor
rotor for damage.
• If there is visible damage, re-
place the sensor rotor.
Refer to “MAINTENANCE OF
THE REAR WHEEL SENSOR
AND SENSOR ROTOR” on
page 4-33.
Fault code No.
21
Symptom
Hydraulic unit solenoid circuit is open or short-
circuited.
Order Item/components and probable
cause
Check or maintenance job
Reinstatement
confirmation
method
1
Open or short circuit in solenoid cir-
cuit.
Replace the hydraulic unit as-
sembly.
• Set the main
switch to “ON”
and check
that the ABS
warning light
comes on for
2 seconds,
then goes off.
• Perform hy-
draulic unit
operation test
1 and check
that the oper-
ation of the
hydraulic unit
is normal.
Summary of Contents for XT1200Z(Z) 2010
