Kubota M7-132, Operator'S Manual

Page: 300 / 332

6. Replacing power steering line
Consult your local KUBOTA Dealer for this service.
7. Replacing lift cylinder hose
Consult your local KUBOTA Dealer for this service.
8. Replacing suspension hose (front
suspension type)
Consult your local KUBOTA Dealer for this service.
9. Replacing differential lock hose
Consult your local KUBOTA Dealer for this service.
10. Replacing brake hose
Consult your local KUBOTA Dealer for this service.
11. Replacing air conditioner hose
Consult your local KUBOTA Dealer for this service.
SERVICE AS REQUIRED
1. Bleeding the fuel system
Air must be removed:
• When the fuel filter or lines are removed.
• When the water is drained from the water
separator.
• When the tank is completely empty.
• After the tractor has not been used for a long period
of time.
The bleeding procedure is as follows:
1. Fill the fuel tank with fuel, and open the fuel shut-off
valve.
(1) Fuel shutoff valve (A) “CLOSE”
(B) “OPEN”
2. Turn “ON” and “OFF” the key switch repeatedly 10
times or so at the following intervals. This lets the
air out of the fuel line.
a. Key switch
“ON” time: 30 seconds
b. Key switch “OFF” time: 15 seconds
(1) Key switch (A) “ON”
(B) “OFF”
3. Set both the hand and the foot throttles to the
maximum speed position, turn the key switch to
start the engine and then reset the throttle at the
mid speed (around 1500 rpm) position.
If the engine doesn’t start, try it several times at 30
second intervals.
IMPORTANT :
• Do not hold the key switch at the engine
start position for more than 10 seconds
continuously. If more engine cranking is
needed, try again after 30 seconds.
4. Accelerate the engine to remove the small portion
of air left in the fuel system.
5. If air still remains and the engine stops, repeat the
previous steps.
2. Bleeding brake system
Consult your local KUBOTA Dealer for this service.
PERIODIC SERVICE EVERY 4 YEARS
294
M7132, M7152, M7172