![background image](http://html1.mh-extra.com/html/eaton/roadranger-trsm4106/roadranger-trsm4106_service-manual_2353178009.webp)
5/01
1/3
General
Lubrication
Proper Oil Level
Before checking the oil level or refilling, vehicle should
be on level ground.
Make sure that the oil is level with the filler opening.
Draining Oil
Drain transmission while oil is warn. To drain oil remove
the drain plug at the bottom if case. Clean the drain plug
before re-installing.
Refilling
Clean area round filler plug.
Fill transmission to the level of the filler opening.
The exact amount of oil depends on the
transmission inclination. In every instance, fill to the
level of the filler opening. Do not overfill this causes
oil to be forced out of the case past the mainshaft and
input shaft seals.
Adding Oil
It is recommended that different types and brands of oil
are not intermixed because of possible incompatibility.
Operating Temprature
It is important that the transmission operating tempera-
ture does not exceed 120¡C (250¡F) for an extended
period of time. Operating temperatures above 120¡C
(250¡F) cause breakdown of the oil and shorten trans-
mission life.
The following conditions in any combination can cause
operating temperatures of over 120¡C (250¡F):
1.
Operating consistently at road speeds
under 32 km/h (20m.p.h.)
2.
High engine RPM
3.
High ambient temperature
4.
Restricted air flow around transmission
5.
Exhaust system too close to transmission
6.
High horsepower, over-drive operation
7.
High power PTO operation for
extensive periods while stationary
High operating temperatures may require more frequent
oil change.
Towing
When towing the vehicle, the propeller shaft between the
axle and transmission must be disconnected.
Summary of Contents for Roadranger TRSM4106
