Page 21-56
21B
E
Installing the Solenoid, Continued:
2. Install the wires on the solenoid as shown in wiring diagram (Figure 21-1, Page 21-2).
DYNAMIC BRAKING SOLENOID
The solenoid is located on the passenger’s side inside of the frame behind the battery compartment. The
solenoid has two sets of posts; two 5/16 inch posts (power contact posts) and two small No. 10 posts (acti-
vating coil posts).
Testing the Solenoid
See Test Procedure 28, Page 21-42.
Removing the Solenoid
1. Disconnect the batteries (Figure 21-2, Page 21-3).
2. Disconnect all wires from the solenoid. Remove the two mounting screws, washers, and nuts (Figure
21-82 or 83, Page 21-55).
Installing the Solenoid
1. Install the solenoid to the mounting bracket and torque to 66 in.lbs. (7.5 N-m). The solenoid does not
have to be oriented in any particular manner (Figure 21-82 or 83, Page 21-55).
2. Install the wires on the solenoid as shown in wiring diagram (Figure 21-1, Page 21-2).
ON-BOARD COMPUTER (OBC)
Testing the On-board Computer
See Test Procedures 13, and 15, on pages 21-32 and 21-34.
Removing the On-Board Computer
1. Disconnect the batteries (Figure 21-2, Page 21-3).
2. Disconnect the10 gauge black wire (to the OBC) from the back of the charger receptacle (Figure 21-1,
Page 21-2).
• TURN THE KEY TO OFF, PUT THE FORWARD AND REVERSE SWITCH IN NEUTRAL, AND DIS-
CONNECT THE BATTERY CABLES AS SHOWN IN FIGURE 21-2, PAGE 21-3. FAILURE TO DO
SO MAY CAUSE THE VEHICLE TO RUN OVER YOU, RESULTING IN SEVERE INJURY OR
DEATH.
• WHEN MAKING ELECTRICAL TESTS OR REPAIRS, ALWAYS:
- WEAR SAFETY GLASSES OR APPROVED EYE PROTECTION.
- REMOVE THE KEY.
- PUT THE FORWARD AND REVERSE SWITCH IN NEUTRAL.
- DISCONNECT THE BATTERIES AS SHOWN (FIGURE 21-2, PAGE 21-3).
- FOLLOW ALL PROCEDURES EXACTLY AS STATED.
• SEE THE SAFTEY WARNINGS ON PAGE 21-53.
DANGER
WARNING
Содержание 1996 DS Golf Car Gasoline
