Club Car 1996 DS Golf Car Gasoline, Руководство по обслуживанию

Страница: 44 / 544

Page 5-6
5
E
G
Rear Body Removal, Continued:
2. Remove two screws and lock nuts located under the mats (one under each mat) in the bagwell floor
(Figure 5-10).
3. Remove two screws located at the bottom edge of the seat support panel (below the Forward and
Reverse shift lever just above the floormat) (Figure 5-11).
4. Remove the screw securing the Forward and Reverse Lever and slide the lever from the shaft.
5. Remove/disconnect vehicle controls:
• Electric vehicles
- Remove the wire tie binding the 10 gauge red wire (from charger receptacle to battery) to Forward
and Reverse Switch wires.
- Remove three screws, hex nuts, and lock washers securing the Forward and Reverse Switch to the
rear body, then pull the Forward and Reverse Switch from the rear body and place it on the vehicle
frame I-beam (with wiring intact).
- Disconnect the three wires from the rear of the charger receptacle (inside the battery compartment)
(See Figure 5-12). The receptacle does not have to be removed from the body.
• Gasoline vehicles
- Remove four screws, hex nuts, and lock washers securing the Forward and Reverse Switch to the
rear body. Pull the Forward and Reverse Switch from the rear body and place it on the vehicle frame
I-beam.
- Remove the shifter cable from the slotted mounting bracket on the rear body.
- Remove the air intake expansion chamber.
FIGURE 5-9
Club
Car
5
3
4
15
14
1
2
6
8
7
3
9
10
11
4
12
13
TYPICAL
4 PLACES
TYPICAL
2 PLACES
TYPICAL
2 PLACES
TYPICAL
8 PLACES
TYPICAL
2 PLACES
TYPICAL
2 PLACES