Club Car Pioneer 900, Руководство по техническому обслуживанию

Страница: 264 / 344

FUEL SYSTEM Fuel Tank
Page 14-24 2001 Pioneer 900 Gasoline Vehicle Maintenance and Service Manual
14
∆ DANGER
• Gasoline! Flammable! Explosive! Do not smoke. Keep sparks and flames away from the
vehicle and service area.
∆ WARNING
• Never attempt to siphon fuel using a hose that does not have a built-in suction device.
• Never attempt to siphon fuel using your mouth.
8. Disconnect the black wire and orange wire from the fuel level sending unit on the tank (Figure 14-18,
Page 14-25). Do NOT remove the lower nut on the center stud of the sending unit. See following
WARNING.
∆ WARNING
• Make sure the key switch is OFF before disconnecting wiring.
9. Remove the vent tube (6) and fuel line (1) from the fuel tank (Figure 14-15, Page 14-20).
10. Loosen the straps (13) and (18) by removing the screws (12) from the speed nuts (11).
11. Lift the fuel tank out of the vehicle.
FUEL TANK DISPOSAL
1. Remove the cap from the tank and thoroughly rinse it with water. The cap may be discarded or kept as
a spare.
2. In a well-ventilated area, flush the fuel tank with water to remove any remaining gasoline.
3. In a well-ventilated area, set the tank upside down so that the water can drain out of it. To make sure
that the tank dries completely, allow the tank to sit for 24 hours. See following CAUTION.
∆ CAUTION
• Dispose of wastewater and fuel tank in accordance with federal, state and local laws and ordinances.
FUEL TANK STORAGE
1. Remove the cap from the tank and thoroughly rinse it with water.
2. In a well-ventilated area, flush the fuel tank with water to remove any remaining gasoline.
3. In a well-ventilated area, set the tank upside down so that the water can drain out of it. To make sure
that the tank dries completely, allow the tank to sit for 24 hours.
4. Store the tank upside down, with the cap installed, in a well-ventilated area.