Club Car Pioneer 900, Руководство по техническому обслуживанию, Страница: 149 / 344

TROUBLESHOOTING AND ELECTRICAL SYSTEM Test Procedures
2001 Pioneer 900 Gasoline Vehicle Maintenance and Service Manual Page 11-41
11
TEST PROCEDURE 27 – HOUR GAUGE
Read DANGER and WARNING on page 11-1.
NOTE: Keep the battery connected while performing this test procedure.
1. Place the Forward/Reverse handle in the NEUTRAL position, and chock the wheels.
2. Turn the key switch to ON and record the current hour gauge reading.
3. Turn the key past the ON position to the START position and hold until the engine is running smoothly.
Release the key and it will return to the ON position and the engine should idle.
4. Allow the engine to idle for at least six minutes (the meter records in six-minute increments). See fol-
lowing DANGER.
∆ DANGER
• Do not operate gasoline vehicle in an enclosed area without proper ventilation. The engine
produces carbon monoxide, which is an odorless, deadly poison.
5. If the reading does not change after six minutes, then replace the fuel/hour gauge.
TEST PROCEDURE 28 – LIGHT SWITCH
Read DANGER and WARNING on page 11-1.
1. Place the Forward/Reverse handle in NEUTRAL, chock the wheels and disconnect the battery, nega-
tive cable first.
2. Remove the center dash assembly. See Key Switch Removal, Section 12, Page 12-15.
3. Using a multimeter set on 20 volts DC, place alligator clips on the multimeter probes. Connect the red
(+) probe to the light switch terminal with the blue wire connected to it (Figure 11-47, Page 11-42).
∆ CAUTION
• Before connecting battery cables, make sure none of the electrical components touch the front body
trim or other parts of the vehicle frame. Place a dry towel between the body trim and the center dash
to prevent an electrical short.
Figure 11-45 Fuel Gauge Test Figure 11-46 Fuel Gauge Voltage Test
2m
20
m
200
m
2k
200
200
200 200
20
2
200
m
500
20k
200k
2000
k
Ω
Ω
1000
OFF
WAVETEK 5XL
V
V
V
A
!
!
COM 200nA
MAX
1000 ---
750V
FUSED
1
3
2
18 GAUGE
BLUE WIRE
TO NO. 1 ON
KEY SWITCH
18 GAUGE BLACK
WIRE TO GROUND
Remove 18 gauge
orange wire to
sending unit.
18 GAUGE
WHITE WIRE
2m
20
m
200
m
2k
200
200
200 200
20
2
200
m
500
20k
200k
2000
k
Ω
Ω
1000
OFF
WAVETEK 5XL
V
V
V
A
! ! COM 200nA
MAX
1000 ---
750V
FUSED
1
3
2
18 GAUGE
ORANGE
WIRE