Club Car Pioneer 900, Руководство по техническому обслуживанию

Страница: 259 / 344

FUEL SYSTEM Fuel Pump
2001 Pioneer 900 Gasoline Vehicle Maintenance and Service Manual Page 14-19
14
FUEL FILTER REMOVAL
1. Access the engine compartment. See DANGER on page 14-1.
1.1. Tilt the bed and ensure that the prop rod is engaged.
2. To prevent gasoline drainage, turn the fuel shut-off valve (15) (Figure 14-15, Page 14-20) on the gas
tank to the closed (OFF) position (Figure 14-20, Page 14-27).
3. Remove the primary fuel filter (17) (Figure 14-15, Page 14-20):
3.1. Remove the clamps (16) and fuel lines (1) and (2) from the filter and plug the fuel lines (Figure
14-15, Page 14-20).
4. Remove the secondary filter (22) (Figure 14-15, Page 14-20):
4.1. Remove the clamps (16 and 20) and fuel lines (3 and 4) from the filter and plug the fuel lines (3
and 4) (Figure 14-15, Page 14-20).
FUEL FILTER INSTALLATION
∆ CAUTION
• Fuel filters are marked with flow direction arrows. Make sure that filters are installed with arrows
pointing in the direction of fuel flow from tank to carburetor.
1. Install the primary fuel filter (17) in the fuel line. Use new clamps (16) (Figure 14-15, Page 14-20).
2. Install the secondary fuel filter (22) in the fuel line. Use new clamps (16 and 20) (Figure 14-15, Page 14-20).
3. Turn the fuel shut-off valve to the ON position (Figure 14-21, Page 14-27).
4. Connect the spark plug wire to the spark plug.
5. Connect the battery cables, positive (+) cable first and tighten terminals to 20 ft-lb (27.1 N·m).
6. Place the Forward/Reverse handle in the NEUTRAL position and chock the wheels. Start the engine
and check for fuel leaks. See following DANGER.
∆ DANGER
• Repair any fuel leaks before operating the vehicle.
FUEL PUMP
Read DANGER and WARNING on page 14-1.
GENERAL INFORMATION
The gasoline vehicle is equipped with an impulse fuel pump. If the fuel pump is not operating properly, per-
form the following tests:
• Make sure all hose clamps are tight.
• Inspect the impulse line and fuel lines for damage or clogging.
• Make sure the air vent on the fuel pump is not clogged with dirt.
• Make sure the fuel filters are not clogged.