![background image](http://html1.mh-extra.com/html/club-car/ds-villager-4/ds-villager-4_maintenance-and-service-manual_2626710434.webp)
21
Fuel Tank
GASOLINE VEHICLE - FUEL SYSTEM
WARNING
• Fuel may be under pressure. Use extreme caution when disconnecting fuel line to prevent the spray of
fuel onto hot engine. See Relieving Fuel Pressure.
• Carefully drain any fuel remaining in the hose or pump module into an approved container. Add
drained fuel back into fuel tank or dispose of properly.
9.
Disconnect fuel pump module ground wire (5).
10.
Remove the screws (6).
11.
Remove the fuel tank retaining strap (7).
12.
Remove the fuel tank (8).
FUEL TANK DISPOSAL
1.
Remove gas cap and fuel pump module from tank. See Fuel Pump Module Removal. The cap may be discarded
or kept as a spare.
2.
In a well-ventilated area, flush the fuel tank with water to remove any remaining fuel.
3.
In a well-ventilated area, set the tank upside down so that the water can drain out of it. To make sure that the tank
dries completely, allow the tank to sit for 24 hours.
See following CAUTION.
CAUTION
• Dispose of wastewater and fuel tank in accordance with local, state, and federal laws and ordinances.
FUEL TANK STORAGE
1.
Remove gas cap and fuel pump module from tank. See Fuel Pump Module Removal.
2.
In a well-ventilated area, flush the fuel tank with water to remove any remaining fuel.
3.
In a well-ventilated area, set the tank upside down so that the water can drain out of it. To make sure that the tank
dries completely, allow the tank to sit for 24 hours.
4.
Completely drain gas from fuel pump module and allow to module to dry.
5.
After the module is completely dry, install it in fuel tank. See Fuel Pump Module Installation.
6.
Store the tank upside down, with the cap installed, in a well-ventilated area.
FUEL TANK INSTALLATION
NOTE:
This gasoline vehicle complies with the California Air Resources Board (CARB) and EPA evaporative
emissions regulations when equipped with SAEJ30R9 1/4 in (6.3 mm) fuel vent hose and 3/16 in (4.78 mm)
fuel vent hose. To remain in compliance with California and EPA regulations, replace any fuel vent hose on
this vehicle with Club Car fuel vent hoses or equivalent.
1.
Install the fuel tank (8) in vehicle
Page 21-22
2020 Precedent,Villager 2 and 4 Maintenance and Service Manual
Summary of Contents for DS Villager 4
