Blue Bird M380 2003, Owner'S Manual

Page: 125 / 579

M380 Owner’s Manual___________________________Interior and Exterior Systems Operation – 12kW Generator – 4-3
Rev. “F” 4-3-1
4-3 12-kW Generator_______
_____________________________
The motor home generator that is supplied
is a Power Tech Ultimate brushless
rotating field generator. It has a speed of
60HZ – 1800 rpm/50HZ – 1500 rpm.
The maximum ambient temperature is
40°C Class F
NOTE: If the generator is operated at
1500 rpm, the voltage and kW rating
will be 5/6 of the 1800-rpm rating.
Consult the manufacture if a higher
voltage or kW rating is required at 50
HZ (1500 rpm).
4-3.1 Generator Operation
The generator can be started and stopped
from any of three locations within the motor home: at the left hand overhead dash inverter panel, at
the left hand lower dash panel, or at the bedroom panel. In addition, the generator can also be
operated from the controller box in the blower/radiator (front roadside) compartment.
To start the generator, push the Generator switch to the
START position. Do not hold the switch on
for longer than 5 seconds at a time! If the generator does not start the first time, wait a minute and try
again. After starting, there will be a delay of approximately 25 seconds before the automatic change
over switch will permit the generator to pick up the load. The generator may be stopped at any time
by momentarily pushing the switch.
4.3.1.1 Safety Guidelines
To avoid personal injury and prevent damage to equipment, it is imperative that all safety precautions
listed below are followed when operating this equipment.
Never Start the Generator with an Electrical Load Applied.
Protect Yourself Against Electrical Shock. Never operate the generator or handle any electrical
equipment while wet, barefoot or while it is raining.
Maintain all Electrical Cords in Good Condition. Worn, frayed or bare wires will cause severe
electrical shock.
Always Disconnect All Electrical Loads Before Working on the Generator.
Always Provide Adequate Ventilation. Engines consumer oxygen and give off deadly carbon
monoxide gases.
4-3.2 Generator Exhaust
The generator exhausts behind the roadside front tire.
CAUTION: The generator exhaust will be hot when the generator is running and for a
time after the generator has been turned off. To avoid burn injuries, allow the
generator exhaust to cool down before any contact with the pipe.