MAINTENANCE AND SERVICING
169469/169470/169471
142
Revision E
b. Remove the eight screws (H) that attach the cover
(J), and remove the cover.
WARNING
To avoid cuts from evaporator fins, do not use
bare hands to brush away clogs.
c. Use a vacuum or compressed air to remove dirt
from inside the unit.
d. Blow compressed air through the evaporator fins
from the blower side first as shown. Direct the air
straight into the evaporator to prevent fin damage.
A nozzle extension would make this procedure
easier.
e. Repeat the previous step from the side opposite
the blowers.
f. If dirt is still present, soak evaporator in water to
loosen dirt, and then blow out with compressed
air.
g. Straighten any bent fins.
h. Re-position cover (J), and attach with eight
screws (H).
i. Re-attach drain hoses to drain tubes, and secure
with hose clamps (G).
7.7.6.5
A/C Compressor Protection
The compressor is protected from excessively low
and high pressures by two switches that shut
down the compressor to prevent damage to the
system. These switches do not require any regular
servicing or maintenance, so if problems occur
and the switches are suspect, contact your Dealer.
If the compressor cycles rapidly due to rapid
pressure changes, the CDM displays a warning
“CHECK A/C SYSTEM”. Contact your Dealer.
7.7.6.6 Refrigerant
and
Oil
IMPORTANT
Perform the following steps whenever the
machine is first started after storage for
more than one week:
1. Ensure heater shut-off valve at engine is
open. See 5.10.1
Heater Shut-off Valve
.
2. Turn blower switch to FIRST position, turn
temperature control switch to MAXIMUM
heating, and A/C control to OFF.
3. Start engine, and operate at low idle until
engine is warm.
4. Click A/C switch from OFF to ON for one
second, then back to OFF for 5–10 seconds.
Repeat this step ten times.
AIR
AIR
AIR
AIR
H
J
OUTSIDE AIR SWITCH
Controls Air Source
Fresh Air – Starts Booster Fan and
Filtered Outside Air Drawn Into Cab.
Recirculate – Stops Booster Fan and
Cab
AIR CONDITIONING SWITCH
Controls A/C System
OFF - A/C Does Not Operate.
ON - A/C Operates With Blower
Switch On.
TEMPERATURE CONTROL
Controls Cab Temperature
Clockwise to Increase.
Counterclockwise to Decrease.
BLOWER SWITCH
Controls Blower Speed
OFF/LOW/MEDIUM/HIGH
Содержание M205 2012
