ROYAL ENFIELD 650 TWIN SERVICE TRAINING MANUAL
167
The front master cylinder hose then joins the front
caliper hose where they pass beneath the fuel tank on
the LH side of the frame. The two hoses are guided by
a cable tie to the ABS modulator bracket and are
connected to the ABS modulator. Underneath the fuel
tank, the ABS hoses, wheel speed sensor wire and main
harness are secured with a cable tie which wraps
around the Y-pressing on the main frame, as shown in
“Fig 6-3” .
The front brake caliper hose routes to the bottom of
the LH fork leg, and is secured to the lower yoke in a
bracket, see “Fig 6-4”.
NOTE:
The wheel speed sensor cable is not retained
in this bracket but is clipped to the hose above and
below the bracket.
Cable tie to
main frame
Cable tie to
ABS bracket
The hose is then connected to the caliper. The ABS
sensor wire is clipped to this hose along the length from
the ABS modulator to the caliper.
ROUTING OF ALL CABLES
1. THROTTLE CABLE ROUTING
The throttle cables are common between the Conti.
GT 650 and Interceptor - 650 variants. They leave
the underside of the switch cube and route around
the front of the RH fork leg, above the headlamp
mount bracket, below the upper yoke.
They pass between the RH fork leg and the
headstock and are located by an omega clip
(PT.No.148554) in the frame as seen in “Fig 1-1”.
Due to lower handlebars on Conti. GT 650, there is
excess length in the throttle cables on this model. To
accommodate the length, the cables should loop
forwards where they pass in front of the RH fork leg.
Omega Clip
(PT.No.1
48554)
Conti. GT 650 Excess length to
loop forwards here
Fig 6-5: Front hose fixing to lower yoke
Fig 6-3:
Y-Pressing
Cable Tie
Fig 6-2-2:
Front
Brake Hose
Headstock
Interceptor-
650 Area 2
Fig 6-6: Front
hose to caliper
Fig 6-4:
Front
brake
hoses to
ABS
modulator
Fig 1-1: Throttle
cables
from
switch cube
Summary of Contents for CONTINENTAL GT 650 TWIN 2018
