Page 137
G
13-18
ENGINE MOUNTING PLATE
On page 13-7 in the 1995-1996 Maintenance and Service Manual, the reference changes as follows:
See Rear Suspension - Gasoline Vehicle, Section 18 in the 1997 Maintenance and Service supple-
ment.
INSTALLATION OF REMAINING ENGINE COMPONENTS
On page 13-22 in the 1995-1996 Maintenance and Service Manual, step 7 under the heading above
changes as follows:
7. Install the spark plug and thread it in until finger tight, then tighten the plug to 20 ft. lbs. (27 N-m).
ENGINE REMOVAL
Because the 1997 engine has only one drain plug, step 15 on page 13-24 in the 1995-1996 Maintenance
and Service Manual, under the heading above changes as follows:
15. Remove the crankcase oil drain plug and filler tube. Tip the engine slightly to allow the oil to drain from
the crankcase. Dispose of oil properly.
ENGINE ASSEMBLY
Because the 1997 engine has only one drain plug, the NOTE under step 18 on page 13-47 in the 1995-1996
Maintenance and Service Manual, under the heading above changes as follows:
SECTION 14 - FUEL SYSTEM
CARBURETOR
The last paragraph under the heading above, on page 14-4 in the 1995-1996 Maintenance and Service Man-
ual should read as follows:
For elevations above 3000 feet, main jets other than standard operate more effectively. Therefore, the follow-
ing chart lists the elevation ratings for various jet sizes. No adjustment is required for the pilot jet. If the vehi-
cle runs roughly at low speeds, turn the pilot screw (8) (Figure 14-4) out until the vehicle runs smoothly.
Usually, not more than one turn of the screw is necessary.
See Maintenance and Service Manual Page 14-4 for Figure 14-4 and chart.
PROCEDURE FOR CHANGING MAIN JET
The governor guard (6) used previously and shown in the 1995-1996 Maintenance and Service Manual in
Figure 14-6 on Page 14-6, is replaced on the 1997 engine by the new governor guard (6) shown in the illus-
tration at the top of page 138.
• DRAIN PLUG IS TO BE TIGHTENED TO 18 - 25 FT. LBS. (24/34 N-M) OF TORQUE.
NOTE
Summary of Contents for 1997 DS
