Taylor TX180S, Maintenance Manual

Page: 228 / 320

17-5 17-5 TX / TXH / TXB 180S - 400L (Rev. 4/23/07) TX / TXH / TXB 180S - 400L (Rev. 4/23/07)
WHEEL WHEEL NUT NUT TORQUE TORQUE VALUES VALUES
 
Steer Axle........340 - 360 ft-lbs (375 - 405 N Steer Axle........340 - 360 ft-lbs (375 - 405 N
⋅ ⋅
m) m)
 
These values are These values are on the tr on the tr uck serial plate uck serial plate
for reference. for reference.
10 10
11 11
2 2
4 4
6 6
7 7
Illustration 17-4. Illustration 17-4. Steer Axle Wheel Nuts Steer Axle Wheel Nuts T T orquing orquing
Sequence (TXH400L) Sequence (TXH400L)
Operation Operation
 
 
Do not overload Do not overload rims or over-i rims or over-i nflate tire / rim nflate tire / rim
assembly. assembly. Check your Check your rim man rim man ufacturer if ufacturer if
special operating conditions are required. special operating conditions are required.
 
Do Do not not use un use un dersized dersized rims. rims. Use r Use r ecom- ecom-
j p j p
 
Remove the Remove the bead seat band bead seat band slowly to p slowly to p re- re-
vent it from dropping off and crushing your vent it from dropping off and crushing your
toes. toes. Support the Support the band on your band on your thigh and thigh and
roll it slowly roll it slowly to the ground to the ground . . This will pro This will pro tect tect
your back and toes. your back and toes.
  When using When using a cable sling, a cable sling, stand clear; it stand clear; it
might snap and lash out. might snap and lash out.
Compressor Precautions Compressor Precautions
There have been instances of tires exploding vio- There have been instances of tires exploding vio-
lently while on lently while on vehicles. vehicles. The forces inv The forces inv olved in olved in
this type explosion are sufficient enough to cause this type explosion are sufficient enough to cause
serious personal injury to anyone in the immediate serious personal injury to anyone in the immediate
vicinity vicinity . . Some of these Some of these explosions are believed explosions are believed to to
have been caused by flammable vapors entering have been caused by flammable vapors entering
the tire the tire during inflation. during inflation. When the When the machine is machine is
operating, the temperature of the air and vapor operating, the temperature of the air and vapor
mixture inside mixture inside the tire will the tire will increase. increase. The tempera- The tempera-
ture inside the tire will also increase with an ture inside the tire will also increase with an
increase in ambient temperature and when sub- increase in ambient temperature and when sub-
jected to direct sunlight. jected to direct sunlight. If the vapor and If the vapor and air mix- air mix-
ture inside the tire are within the ratio limits that ture inside the tire are within the ratio limits that
will support combustion, and any or all of the will support combustion, and any or all of the
above heat increasing factors cause the tempera- above heat increasing factors cause the tempera-
ture to rise, an explos ture to rise, an explos ion may occur ion may occur . . The follow- The follow-
ing are some warnings that can prevent flam- ing are some warnings that can prevent flam-
mable vapors from entering the compressor and mable vapors from entering the compressor and
subsequently being entrapped in tires. subsequently being entrapped in tires.
 
 
Do not Do not locate the com locate the com pressor in pressor in a utility a utility
room used for storing flammable solvents, room used for storing flammable solvents,
paints, thinn paints, thinn ers, etc. ers, etc. The flammab The flammab le vapors le vapors
will be sucked into the compressor intake will be sucked into the compressor intake
while the compressor is charging. while the compressor is charging.
 
Do not clean th Do not clean th e compressor air e compressor air filter with a filter with a
flammable flammable solvent. solvent. Use a Use a non-flammable non-flammable
solvent, such as carbon tetrachloride. solvent, such as carbon tetrachloride.
 
Do not use al Do not use al cohol, methanol cohol, methanol , or other , or other
flammable agents in the compressor to pre- flammable agents in the compressor to pre-
vent freezing of the condensation inside the vent freezing of the condensation inside the
compressor. compressor. Drain th Drain th e compr e compr essor tank essor tank
frequently or locate the compressor inside to frequently or locate the compressor inside to
eliminate the freezing problem. eliminate the freezing problem.
 
Do not l Do not l ocate the compr ocate the compr essor near a essor near a battery battery
charger. charger. Batteries emit Batteries emit hydrogen gas, hydrogen gas, which which
is highly flammable, during the is highly flammable, during the charging pro- charging pro-
cess, and could be sucked into the compres- cess, and could be sucked into the compres-
sor intake. sor intake.
1 1 . . D D R R I I V V E E A A X X L L E E
2 2 . . R R I I M M
3 3 . . N N U U T T
4 4 . . R R I I M M
5 5 . . S S I I D D E E R R I I N N G G
6 6 . . L L O O C C K K R R I I N N G G
4 4
6 6
5 5
https://www.forkliftpdfmanuals.com/