agrifac Condor C03, User Manual

Page: 162 / 250

MAINTENANCE
162
Condor-UM-2011-21-R0-en-us-20210108
6.8 Compressed air supply
Compressor:
The compressor on the engine supplies compressed air. The compressor is lubricated by the en-
gine oil. Check the condition of the air hose in between the air filter and the compressor. Replace
the hose if necessary.
Compressed air tanks:
CAUTION Compressed air.
Air or flying debris can cause injury.
Use safety goggles.
If any dirty water condensate gets in
your eyes: immediately rinse your eyes
with plenty of water. Get medical aid if
eye irritation occurs.
Drain the water condensate every 50 operating
hours. Replace the air dryer cartridge if necessary.
Draining the water condensate:
Pull the ring [1] sideways or push the valve [2] IN
until the water is removed.
Air dryer cartridge:
A replacement kit contains 1 car-
tridge and 1 O-ring.
Replace the cartridge 1x per year.
Replacing the cartridge:
1. Turn the engine off and take the ignition key
with you.
2. Exhaust all tanks: pull the ring [1] sideways
or push the valve [2] IN until the air has es-
caped.
3. Remove the plate [3].
4. Remove the old cartridge [4] with a filter
wrench.
5. Remove the old O-ring [5].
6. Clean the contact surface [6].
7. Install the new O-ring [7].
8. Apply grease on the O-ring [7], on the screw
thread [8] and on the seal [9] of the new car-
tridge. The grease makes future cartridge
removal easier.
9. Screw on the cartridge until the seal [9]
touches the dryer. Tighten the cartridge with
an additional ½ turn.
10. Install the plate [3].