Club Car CARRYALL 1 2000, Руководство по техническому обслуживанию и ремонту

Страница: 73 / 136

2000 Turf/Carryall Vehicle Maintenance and Service Manual Page 6-1
6
SECTION 6 – WHEEL BRAKE ASSEMBLIES
• ONLY TRAINED TECHNICIANS SHOULD REPAIR OR SERVICE THIS VEHICLE. ANYONE DOING
EVEN SIMPLE REPAIRS OR SERVICE SHOULD HAVE KNOWLEDGE AND EXPERIENCE IN
ELECTRICAL AND MECHANICAL REPAIR. FOLLOW ALL PROCEDURES EXACTLY AND HEED
ALL WARNINGS STATED IN THIS MANUAL.
• WEAR SAFETY GLASSES OR APPROVED EYE PROTECTION WHILE SERVICING VEHICLE.
WEAR A FULL FACE SHIELD WHEN WORKING WITH BATTERIES.
• SOME BRAKE SHOES CONTAIN ASBESTOS FIBER AND ASBESTOS DUST IS CREATED WHEN
THESE BRAKE MECHANISMS ARE HANDLED. WEAR APPROVED EYE AND RESPIRATORY
PROTECTION WHEN DISASSEMBLING AND CLEANING BRAKE MECHANISMS. INHALATION
OF ASBESTOS COULD RESULT IN SEVERE PERSONAL INJURY OR DEATH. DO NOT USE
COMPRESSED AIR OR AEROSOL SPRAYS TO CLEAN THE BRAKE MECHANISM. CLEAN
BRAKE MECHANISMS USING THE NEGATIVE PRESSURE ENCLOSURE/HEPA VACUUM
SYSTEM OR LOW PRESSURE/WET CLEANING METHOD PER OSHA/29 CFR -1910.1001.
• TURN KEY SWITCH OFF , PLACE FORWARD/REVERSE HANDLE IN THE NEUTRAL POSITION
AND REMOVE KEY PRIOR TO SERVICING.
• DO NOT WEAR LOOSE CLOTHING. REMOVE JEWELRY SUCH AS RINGS, WATCHES, CHAINS,
ETC. BEFORE SERVICING VEHICLE.
• MOVING PARTS! - DO NOT ATTEMPT TO SERVICE THE VEHICLE WHILE IT IS RUNNING.
• LIFT ONLY ONE END OF THE VEHICLE AT A TIME. BEFORE LIFTING, LOCK THE BRAKES,
UNLOAD THE CARGO BED AND CHOCK THE WHEELS THAT REMAIN ON THE FLOOR. USE A
SUITABLE LIFTING DEVICE (CHAIN HOIST OR HYDRAULIC FLOOR JACK) WITH 1000 LB. (454
KG.) MINIMUM LIFTING CAPACITY. DO NOT USE LIFTING DEVICE TO HOLD VEHICLE IN
RAISED POSITION. ALWAYS USE APPROVED JACK STANDS OF PROPER WEIGHT CAPACITY
TO SUPPORT THE VEHICLE.
• USE INSULATED TOOLS WHEN WORKING NEAR BATTERIES OR ELECTRICAL
CONNECTIONS.
GASOLINE VEHICLES ONLY:
• TO AVOID UNINTENTIONALLY STARTING THE VEHICLE ALWAYS:
- DISCONNECT BATTERY CABLES, NEGATIVE (–) FIRST.
- DISCONNECT THE SPARK PLUG WIRE FROM THE SPARK PLUG.
• FRAME GROUND - DO NOT ALLOW TOOLS OR OTHER METAL OBJECTS TO CONTACT
FRAME WHEN DISCONNECTING BATTERY CABLES OR OTHER ELECTRIC WIRING. NEVER
ALLOW A POSITIVE WIRE TO TOUCH THE VEHICLE FRAME, ENGINE OR OTHER METAL
COMPONENT.
ELECTRIC VEHICLES ONLY:
• TO AVOID UNINTENTIONALLY STARTING THE VEHICLE, DISCONNECT BATTERIES AS
SHOWN IN
SECTION 1, FIGURE 1-2 , PAGE 1-3 , THEN DISCHARGE THE CONTROLLER AS
FOLLOWS:
- TURN THE KEY SWITCH TO ON AND PLACE THE FORWARD/REVERSE HANDLE IN THE
REVERSE POSITION.
- SLOWLY DEPRESS THE ACCELERATOR PEDAL AND KEEP IT DEPRESSED UNTIL THE
REVERSE WARNING BUZZER CAN NO LONGER BE HEARD. WHEN THE BUZZER STOPS
SOUNDING, THE CONTROLLER IS DISCHARGED.
WARNING