Club Car CARRYALL 1 2000, Руководство по техническому обслуживанию и ремонту

Страница: 37 / 136

2000 Turf/Carryall Vehicle Maintenance and Service Manual Page 4-1
4
SECTION 4 – BODY AND TRIM
CLEANING THE VEHICLE
Each vehicle is equipped with an injection molded ArmorFlex ® front body and aluminum rear body. Use a
mild soap or detergent with a sponge or soft cloth for normal cleaning. Battery acid, fertilizers, tars, asphalt,
creosote, paint, or chewing gum should be removed immediately to prevent possible stains. Because the fin-
ish on the front body is the same as the finish on today’s automobiles, commercial automotive cleaning prod-
ucts should be used. For general cleaning of the aluminum rear body, use a mild liquid soap and a sponge or
soft bristle brush. To remove oxidation or discoloration from aluminum, use a commercially available alumi-
num cleaner paste and fine grade (No. 00) steel wool.
• ONLY TRAINED TECHNICIANS SHOULD REPAIR OR SERVICE THIS VEHICLE. ANYONE DOING
EVEN SIMPLE REPAIRS OR SERVICE SHOULD HAVE KNOWLEDGE AND EXPERIENCE IN
GENERAL BODY AND PAINT REPAIR. FOLLOW ALL PROCEDURES EXACTLY AND HEED ALL
WARNINGS STATED IN THIS MANUAL.
• WEAR SAFETY GLASSES OR APPROVED EYE PROTECTION WHILE SERVICING THE
VEHICLE. WEAR A FULL FACE SHIELD WHEN WORKING WITH BATTERIES.
• WEAR A RESPIRATOR APPROVED FOR DUST AND PAINT MIST WHEN CUTTING, SANDING,
PAINTING, OR REPAIRING BODY PANELS.
• TURN KEY SWITCH OFF , PLACE FORWARD/REVERSE HANDLE IN THE NEUTRAL POSITION,
AND REMOVE KEY BEFORE SERVICING THE VEHICLE.
• DO NOT WEAR LOOSE CLOTHING. REMOVE JEWELRY SUCH AS RINGS, WATCHES, CHAINS,
ETC. BEFORE SERVICING VEHICLE.
• USE INSULATED TOOLS WHEN WORKING NEAR BATTERIES OR ELECTRICAL CONNECTIONS.
• MOVING PARTS! - DO NOT ATTEMPT TO SERVICE VEHICLE WITH THE ENGINE/MOTOR
RUNNING.
• HOT! - DO NOT ATTEMPT TO SERVICE HOT MOTOR, ENGINE OR EXHAUST SYSTEM.
FAILURE TO HEED THIS WARNING CAN RESULT IN SEVERE BURNS.
• GASOLINE VEHICLE: TO AVOID UNINTENTIONALLY STARTING THE VEHICLE, DISCONNECT
THE SPARK PLUG WIRE FROM THE PLUG.
• ELECTRIC VEHICLE: TO AVOID UNINTENTIONALLY STARTING THE VEHICLE, DISCONNECT
BATTERIES AS SHOWN IN SECTION 1, FIGURE 1-2, PAGE 1-3. THEN DISCHARGE THE
CONTROLLER AS FOLLOWS:
- TURN THE KEY SWITCH TO ON AND PLACE THE FORWARD/REVERSE HANDLE IN THE
REVERSE POSITION.
- SLOWLY DEPRESS THE ACCELERATOR PEDAL AND KEEP IT DEPRESSED UNTIL THE
REVERSE WARNING BUZZER CAN NO LONGER BE HEARD. WHEN THE BUZZER STOPS
SOUNDING, THE CONTROLLER IS DISCHARGED.
• DO NOT USE DETERGENTS OR CLEANING SOLVENTS THAT CONTAIN AMMONIA, AROMATIC
SOLVENTS OR ALKALI MATERIALS ON BODY PANELS OR SEATS.
• DO NOT ALLOW BATTERY ACID TO DRIP ON BODY PANELS. BATTERY ACID WILL CAUSE
PERMANENT DAMAGE. WASH SPILLED BATTERY ACID FROM BODY PANELS IMMEDIATELY.
WARNING
CAUTION