Not for
Reproduction
12
• Do not use a battery that has been crushed, dropped, or damaged.
Used and discarded battery packs will likely still carry a small electrical charge and
should be handled with care. Always dispose of discarded or used battery packs
according to federal, state and local regulations.
Storage
WARNING
Fuel and its vapors are extremely flammable and explosive.
Fire or explosion can cause severe burns or death.
Electrical Shock
When Storing Fuel Or Equipment With Fuel In Tank
• Store away from furnaces, stoves, water heaters or other appliances that have
pilot lights or other ignition sources because they can ignite fuel vapors.
When Storing Battery Pack and Battery Charger
• Keep battery charger dry. Avoid exposing battery pack to rain or wet conditions.
Fuel System
See Figure: 22
Note:
Some models have a fuel tank for vertical storage that will let the engine tilt for
maintenance or storage. Do not store in vertical position with fuel tank filled above the
bottom of the fuel tank neck. For further instructions, see the equipment manual.
Store the engine level (normal operating position). Fill fuel tank (A, Figure 22) with fuel.
To allow for expansion of fuel, do not overfill above the fuel tank neck (B).
Fuel can become stale when kept in a storage container for more than 30 days. Each
time you fill the container with fuel, add fuel stabilizer to the fuel as specified by the
manufacturer’s instructions. This keeps fuel fresh and decreases fuel-related problems
or contamination in the fuel system.
It is not necessary to drain fuel from the engine when fuel stabilizer is added as
instructed. Before storage, turn the engine ON for 2 minutes to move the fuel and
stabilizer through the fuel system.
If gasoline in the engine has not been treated with a fuel stabilizer, it must be drained
into an approved container. Run the engine until it stops from lack of fuel. The use of a
fuel stabilizer in the storage container is recommended to maintain freshness.
Engine Oil
While the engine is still warm, change the engine oil. See the
Change Engine Oil
section.
Battery Pack and Charger
See Figure: 23
Portable battery pack:
When not in use, disconnect charger and store in a cool, dry
area. Wet, damp areas can cause corrosion of terminals and electrical contacts. If stored
for long periods in high temperatures (120° F / 49° C), permanent damage to the battery
pack can result. Check electrical terminals and contacts on battery packs and charger.
Wipe with clean cloth or blow clean with compressed air.
After storage, a normal charge may be required. To check available charge, press the
Battery Fuel Gauge button (E, Figure 23 ) and charge if required. See the
Battery Fuel
Gauge
section.
Troubleshooting
Need assistance? Contact your local dealer or go to
BRIGGSandSTRATTON.com
.
Specifications
Model: 100600, 100800
Displacement
9.82 ci (161 cc)
Bore
2.520 in (64,01 mm)
Stroke
1.968 in (49,99 mm)
Oil Capacity
18 - 20 oz (,54 - ,59 L)
Spark Plug Gap
.020 in (,51 mm)
Spark Plug Torque
180 lb-in (20 Nm)
Armature Air Gap
.006 - .014 in (,15 - ,36 mm)
Intake Valve Clearance
.004 - .006 in (,10 - ,15 mm)
Model: 100600, 100800
Exhaust Valve Clearance
.014 - .016 in (,36 - ,41 mm)
Lithium-Ion Battery
Lithium-Ion Battery Pack
10.8 V (10,8 V)
Charge Minutes
60
Charging Current
2 AMP (2 AMP)
Charger AC Input (Variable)
90 - 240 V
Operating Temperature
32 - 113 F (0 - 45 C)
Engine power will decrease 3.5% for each 1,000 feet (300 meters) above sea level and
1% for each 10° F (5.6° C) above 77° F (25° C). The engine will operate satisfactorily
at an angle up to 15°. Refer to the equipment operator's manual for safe allowable
operating limits on slopes.
Service Parts - Model: 100600, 100800
Service Part
Part Number
Air Filter (Figure 18)
792038
Pre-cleaner (Figure 18)
793676
Air Filter (Figure 19)
590601
Pre-cleaner (Figure 19)
590602
Oil - SAE 30
100005
Fuel Filter
298090, 5018
Resistor Spark Plug
692051, 692720
Spark Plug Wrench
89838, 5023
Spark Tester
19368
Lithium-Ion Battery Pack (EU, UK, AU)
593560
Lithium-Ion Battery Charger (EU)
593562
Lithium-Ion Battery Charger (UK)
593576
Lithium-Ion Battery Charger (AU)
594501
We recommend that you see any Briggs & Stratton Authorized Dealer for all
maintenance and service of the engine and engine parts.
Power Ratings:
The gross power rating for individual gasoline engine models is
labeled in accordance with SAE (Society of Automotive Engineers) code J1940 Small
Engine Power & Torque Rating Procedure, and is rated in accordance with SAE J1995.
Torque values are derived at 2600 RPM for those engines with “rpm” called out on the
label and 3060 RPM for all others; horsepower values are derived at 3600 RPM. The
gross power curves can be viewed at www.BRIGGSandSTRATTON.COM. Net power
values are taken with exhaust and air cleaner installed whereas gross power values
are collected without these attachments. Actual gross engine power will be higher than
net engine power and is affected by, among other things, ambient operating conditions
and engine-to-engine variability. Given the wide array of products on which engines
are placed, the gasoline engine may not develop the rated gross power when used in a
given piece of power equipment. This difference is due to a variety of factors including,
but not limited to, the variety of engine components (air cleaner, exhaust, charging,
cooling, carburetor, fuel pump, etc.), application limitations, ambient operating conditions
(temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing
and capacity limitations, Briggs & Stratton may substitute an engine of higher rated
power for this engine.
Warranty
Briggs & Stratton Engine Warranty
Effective January 2019
Limited Warranty
Briggs & Stratton warrants that, during the warranty period specified below, it will repair
or replace, free of charge, any part that is defective in material or workmanship or
both. Transportation charges on product submitted for repair or replacement under this
warranty must be borne by purchaser. This warranty is effective for and is subject to
the time periods and conditions stated below. For warranty service, find the nearest
Authorized Service Dealer in our dealer locator map at BRIGGSandSTRATTON.COM.
The purchaser must contact the Authorized Service Dealer, and then make the product
available to the Authorized Service Dealer for inspection and testing.
There is no other express warranty. Implied warranties, including those of
merchantability and fitness for a particular purpose, are limited to the warranty
period listed below, or to the extent permitted by law.
Liability for incidental or
consequential damages are excluded to the extent exclusion is permitted by law. Some
