7B1
AUTOMATIC TRANSMISSION (4 A / T)
7B1-1
GENERAL DESCRIPTION
7B1- 3
. . . . . . . . . . . . . .
CLUTCH / BRAKE FUNCTIONS
7B1- 5
. . . . . . . .
TABLE OF COMPONENT
OPERATION
7B1- 6
. . . . . . . . . . . . . . . . . . . . . . .
ELECTRONIC SHIFT CONTROL
SYSTEM
7B1- 7
. . . . . . . . . . . . . . . . . . . . . . . . . . .
CHANGE MECHANISM
7B1- 9
. . . . . . . . . . . . .
OPERATION OF SHIFT SOLENOIDS
AND TCC SOLENOID
7B1- 9
. . . . . . . . . . . . .
AUTOMATIC GEAR SHIFT DIAGRAM 7B1-10
DIAGNOSIS
7B1-11
. . . . . . . . . . . . . . . . . . . . . . . . . . .
ON-BOARD DIAGNOSTIC SYSTEM
7B1-11
. . . .
PRECAUTION IN DIAGNOSING
TROUBLE
7B1-12
. . . . . . . . . . . . . . . . . . . . . . . . . .
AUTOMATIC TRANSMISSION
DIAGNOSTIC FLOW TABLE
7B1-13
. . . . . . . . . .
“O / D OFF” LAMP CHECK
7B1-16
. . . . . . . . . . . . .
DIAGNOSTIC TROUBLE CODE (DTC)
CHECK
7B1-16
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DIAGNOSTIC TROUBLE CODE
CLEARANCE
7B1-18
. . . . . . . . . . . . . . . . . . . . . . .
DIAGNOSTIC TROUBLE CODE
TABLE
7B1-19
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FAIL SAFE TABLE
7B1-20
. . . . . . . . . . . . . . . . . . . .
VISUAL INSPECTION
7B1-21
. . . . . . . . . . . . . . . .
A / T BASIC CHECK
7B1-21
. . . . . . . . . . . . . . . . . . .
TROUBLE DIAGNOSIS TABLE 1
7B1-22
. . . . . . .
TROUBLE DIAGNOSIS TABLE 2
7B1-23
. . . . . . .
TROUBLE DIAGNOSIS TABLE 3
7B1-24
. . . . . . .
ROAD TEST
7B1-25
. . . . . . . . . . . . . . . . . . . . . . . . .
MANUAL ROAD TEST
7B1-26
. . . . . . . . . . . . . . . .
ENGINE BRAKE TEST
7B1-27
. . . . . . . . . . . . . . . .
STALL TEST
7B1-27
. . . . . . . . . . . . . . . . . . . . . . . . .
TIME LAG TEST
7B1-29
. . . . . . . . . . . . . . . . . . . . .
LINE PRESSURE TEST
7B1-30
. . . . . . . . . . . . . . .
P RANGE TEST
7B1-31
. . . . . . . . . . . . . . . . . . . . . .
TABLE A-1: NO GEAR SHIFT TO
O / D
7B1-32
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TABLE A-2: NO LOCK-UP OCCURS
7B1-33
. . . .
TABLE B-1: “O / D OFF” LAMP
CIRCUIT CHECK (“O / D OFF” LAMP
DOESN’T LIGHT AT IGNITION SWITCH
ON)
7B1-34
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TABLE B-2: “O / D OFF” LAMP
CIRCUIT CHECK (“O / D OFF” LAMP
COMES ON STEADILY)
7B1-35
. . . . . . . . . . . . . .
INSPECTION OF TCM AND ITS
CIRCUITS
7B1-36
. . . . . . . . . . . . . . . . . . . . . . . . . .
WIRE HARNESS AND
CONNECTORS
7B1-36
. . . . . . . . . . . . . . . . . . . . .
DTC P0705 – TRANSMISSION
RANGE SENSOR (SWITCH) CIRCUIT
MALFUNCTION
7B1-37
. . . . . . . . . . . . . . . . . . . . .
DTC P0710 TRANSMISSION FLUID
TEMPERATURE SENSOR CIRCUIT
MALFUNCTION
7B1-40
. . . . . . . . . . . . . . . . . . . . .
SECTION 7B1
AUTOMATIC TRANSMISSION (4 A/T)
WARNING:
For vehicles equipped with Supplemental Restraint (Air Bag) System :
D
Service on and around the air bag system components or wiring must be performed only by an autho-
rized SUZUKI dealer. Refer to “Air Bag System Components and Wiring Location View” under “Gener-
al Description” in air bag system section in order to confirm whether you are performing service on
or near the air bag system components or wiring. Please observe all WARNINGS and “Service Precau-
tions” under “On-Vehicle Service” in air bag system section before performing service on or around
the air bag system components or wiring. Failure to follow WARNINGS could result in unintentional
activation of the system or could render the system inoperative. Either of these two conditions may
result in severe injury.
D
Technical service work must be started at least 90 seconds after the ignition switch is turned to the
“LOCK” position and the negative cable is disconnected from the battery. Otherwise, the system may
be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
CONTENTS
