Suzuki Engine 2002 GRAND VITARA SQ625, Service Manual

Page: 636 / 834

ENGINE AND EMISSION CONTROL SYSTEM (G16/J20 ENGINES) 6E1-5
1. Air cleaner 32. Malfunction indicator lamp
2. Intake air temp. sensor 33. “O/D OFF” lamp
3. Mass air flow sensor 34. “POWER” lamp
4. Throttle body 35. Starter
5. Idle air control valve 36. Park/Neutral position switch in TR switch (A/T)
6. Throttle position sensor 37. Main relay
7. EVAP canister purge valve 38. Main switch
8. A/C condenser fan motor through relay (if equipped) 39. Main fuse
9. Manifold absolute pressure sensor (if equipped) 40. Battery
10. Warm-up three way catalytic converter (if equipped) 41. EGR valve (if equipped)
11. Vehicle speed sensor 42. Three way catalytic converter (if equipped)
12. Ignition coil assembly for No.1 and No.4 spark plugs 43. Engine coolant temp. sensor
13. Ignition coil assembly for No.2 and No.3 spark plugs 44. Fuel injectors
14. Camshaft position sensor 45. PCV valve
15. Transmission range switch (sensor) (A/T) 46. Heated oxygen sensor-1 (if equipped)
16. A/T input speed sensor 47. Fuel pressure regulator
17. A/T vehicle (output) speed sensor (A/T) 48. Fuel filter
18. Shift solenoid valve A (A/T) 49. Fuel pump with fuel level sensor
19. Shift solenoid valve B (A/T) 50. EVAP canister
20. TCC solenoid valve (A/T) 51. Data link connector
21. ECM/PCM (Engine control module/Powertrain control module) 52. Ignition timing adjusting resistor (if equipped)
22. ABS control module (if equipped) 53. CO adjusting resistor (if equipped)
23. A/C control module (amplifier) (canvas top model, if equipped),
HVAC control module (other than canvas top model)
54. 4WD switch
23-1. A/C refrigerant pressure switch (other than canvas top model, if
equipped)
55. 4WD lamp
24. Electric load (s)
– Heater blower motor (canvas top model, if equipped)
– Rear defogger (if equipped)
– Lighting
56. Immobilizer indicator lamp (if equipped)
25. Power steering pressure switch (if equipped) 57. A/C compressor relay (other than canvas top model, if
equipped)
26. Stop lamp switch (A/T) 58. Combination meter
27. Power/Normal change switch (A/T) 59. Diagnosis connector (if equipped)
28. O/D cut switch (A/T) 59-1. Diagnosis switch terminal
29. 4WD low switch (A/T) 59-2. Test switch terminal
30. Heated oxygen sensor-2 (if equipped) 59-3. Duty output terminal
31. Crankshaft position sensor (if equipped)