Vertiv
|
XTE 802 Series Walk-In-Cabinet (WIC) Description & Installation Manual (631-205-434)
|
Rev. D
66
WIC and Generator Combo Concrete/Gravity Platform Installation (P/N D1000-0010-0123)
This platform is designed to be set on grade or concrete and it accommodates both the WIC and all ATT
approved generators. Stairs can be mounted on either side and the WIC can be mounted in any direction to
support any site layout. WIC, generator, conduits, cabling, Raycaps, etc. is installed at WWT so a completely
configured platform can be installed at the site. The legs use single-bolt leveling and are pre-installed. Simply
lift and set on grade or concrete. Anchor holes are provided for anchoring into concrete. Platform includes a
rodent guard for generators that need it which is also installed at WWT if the generator is installed at WWT. If
Generator is installed at the site, see “Generator Wings Installation Procedure”. See
Grade Considerations
1.
Ground/gravel should be normally dry and have good drainage.
2.
Ground/gravel should be level or very close.
Concrete Pier Installation Considerations
1.
Height of concrete piers must be constructed to grade level. If grade is not level, maintain an 18 inch
height between grade and the WIC base on the side with the door. The 18 inch height is required for the
stairs to mount properly.
2.
Depth of concrete piers must be determined by region and take into consideration such items but not
limited to depth of frost line, soil type, general climate conditions, and site drainage.
3.
4000 PSI concrete strength should be considered as a minimum type of pier construction, but can vary
based on local architectural standards and approvals.
4.
Maximum pier diameter: 30 inches
5.
Minimum pier diameter: 18 inches.
6.
Anchor bolts can be drilled in the concrete piers after the platform is set. Be sure to align all nine
concrete piers under each of three connection points under each of three skis. Anchor hardware could
be anything between a 5/8 inch anchor (would need washers) to a 1 inch anchor (no washers needed).
7.
WIC fully loaded is 6500 lbs.
8.
Platform is 2050 lbs.
9.
Heaviest Generator with full tank is 4436 lbs.
10.
Generator Wing Kit is 207 lbs.
Existing Concrete Pad Considerations
1.
Concrete area should be a minimum of 110" x 184" if the concrete is at grade level. This leaves one foot
around the base of the WIC and does not accommodate the stairs.
2.
Concrete area should be a minimum of 134" x 184" if above grade to accommodate for the stairs.
3.
WIC fully loaded is 6500 lbs.
4.
Platform is 2050 lbs.
5.
Heaviest Generator with full tank is 4436 lbs.
6.
Generator Wing Kit is 207 lbs.
